Auto Parts Search
2006 Pontiac Montana CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Pontiac REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2006 Pontiac Montana AUTOMOBILES
Power Brake Units -> Delco Brake Booster -> General Service
Vehicle: 2006 Pontiac Montana SV6 3.5 V6 GAS
Certain general service procedures apply, regardless of whether the brakes are vacuum or hydraulically assisted. Only top quality, clean brake fluid should be used. More seals and valves are used with power brake systems than with ordinary brakes, so an inferior brake fluid will do much more damage. For the same reason, ensure all dirt is kept out of the system. Additionally, on models with hydraulic assist brakes, care must be taken not to mix the fluids of the booster hydraulic system and brake hydraulic system as the fluids are not compatible.
If the power unit fails, the brak...
CLICK HERE TO GET FULL ACCESS TO 2006 Pontiac Montana BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2006 Pontiac Montana AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Filter Scheduled Maintenance -> Montana SV6, Relay, Terraza & Uplander -> Normal Service -> Severe Service
Vehicle: 2006 Pontiac Montana SV6 3.5 V6 GAS
Normal Service
...
CLICK HERE TO GET FULL ACCESS TO 2006 Pontiac Montana FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2006 Pontiac Montana AUTOMOBILES
CV AXLE SHAFT, Replace -> Front -> Rear
Vehicle: 2006 Pontiac Montana SV6 3.9 V6 GAS
Front
- Raise and support vehicle, then remove tire and wheel assembly.
- Remove engine splash shield.
- Insert a suitable drift or punch through brake caliper and into brake rotor to prevent wheel hub and bearing from turning.
- Remove wheel drive shaft spindle nut.
- Remove stabilizer shaft link.
- Disconnect outer tie rod end from steering knuckle. Do not loosen tie rod end jam nut.
- Disconnect wheel speed sensor electrical connector, then reposition wiring harness away from ball joint.
- Disconnect lower ball joint from steering knuckle.
- Install wheel hub remover tool No. J 42129, or equival...
CLICK HERE TO GET FULL ACCESS TO 2006 Pontiac Montana DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2006 Pontiac Montana AUTOMOBILES
Starter, Replace
Vehicle: 2006 Pontiac Montana SV6 3.5 V6 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- Disconnect starter electrical connectors.
- Remove converter cover.
- Remove starter motor ...
CLICK HERE TO GET FULL ACCESS TO 2006 Pontiac Montana STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2006 Pontiac Montana AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 2005-07 Montana SV6, Relay, Terraza & 2005-08 Uplander
Vehicle: 2006 Pontiac Montana SV6 3.5 V6 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles or at Maintenance II as indicated on the DIC (Driver Information Center). In dusty areas change the cabin air filter more often.
- Open the glove compartment door.
- Remove the rear inside instrument panel compartment door.
- Open the cabin filter access door, Fig. .
- Remove the righthand cabin ...
CLICK HERE TO GET FULL ACCESS TO 2006 Pontiac Montana CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2006 Pontiac Montana AUTOMOBILES
General Motors Corp./Saturn Trucks -> Check Engine Oil Level ->
Vehicle: 2006 Pontiac Montana SV6 3.5 V6 GAS
This system is used to indicate a low engine oil level condition. The lamp should light during engine starting. If oil level is sufficient, the lamp should go off when engine is operating. If oil level is low the...
CLICK HERE TO GET FULL ACCESS TO 2006 Pontiac Montana MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2006 Pontiac Montana AUTOMOBILES
Radiator, Replace
Vehicle: 2006 Pontiac Montana SV6 3.9 V6 GAS
- Drain engine coolant into a suitable container.
- Disconnect and plug lower transmission oil cooler line from radiator.
- Remove righthand side diagonal brace and radiator inlet hose.
- Disconnect cooling fan harness electrical connector.
- Loosen engine mount strut nuts from engine side of strut.
- Remove engine mount strut bracket brace bolts from upper radiator support, then rotate struts and brackets rearward.
- Position coolant overflow hose from reservoir.
- Remove overflow...
CLICK HERE TO GET FULL ACCESS TO 2006 Pontiac Montana RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2006 Pontiac Montana AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2006 Pontiac Montana SV6 3.9 V6 GAS
- Rotate or lift belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 2006 Pontiac Montana SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2006 Pontiac Montana AUTOMOBILES
Component location diagrams for most 2006 Pontiac Montana cars and light trucks sold in the U.S. from 1990+.
Fuel Tank Diagram for 2006 Pontiac Montana SV6 3.9 V6 GAS Components on diagram: |
Heated Oxygen Sensor Location Diagram for 2006 Pontiac Montana SV6 3.5 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Pontiac Montana PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2006 Pontiac Montana AUTOMOBILES
OEM drawn wiring diagrams for most 2006 Pontiac Montana cars and light trucks sold in the U.S.
2006 Pontiac Montana SV6 3.9 V6 GAS Wiring Diagram Components on diagram: |
2006 Pontiac Montana SV6 3.9 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Pontiac Montana WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2006 Pontiac Montana AUTOMOBILES
OEM TSB listings for most 2006 Pontiac Montana cars and light trucks sold in the U.S. from 1985+.
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2006 Pontiac Montana SV6 3.5 V6 GAS Auto Systems: |
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2006 Pontiac Montana SV6 3.5 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2006 Pontiac Montana TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2006 Pontiac Montana AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2006 Pontiac Montana cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2006 Pontiac Montana cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2006 Pontiac Montana cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2006 Pontiac Montana cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2006 Pontiac Montana SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2006 Pontiac Montana vehicle. |
Access the Complete guide! |