Auto Parts Search
2006 Nissan Titan CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Nissan REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
FUEL FILTER REPLACEMENT PROCEDURES FOR 2006 Nissan Titan AUTOMOBILES
Nissan/Datsun -> Fuel Filter Replacement -> Titan -> Fuel System Pressure Relief -> Removal & Installation
Vehicle: 2006 Nissan Titan LE 5.6 V8 FLEX
Fuel System Pressure Relief
- Remove the fuel pump fuse from the fuse panel.
- Start and run the engine until it stalls.
- After the engine stalls, crank two or three times to ensure all fuel pressure is relieved.
- Turn the ignition Off, then install the fuel pump fuse.
Removal & Installation
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental fuel spray.
After the b...
CLICK HERE TO GET FULL ACCESS TO 2006 Nissan Titan FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2006 Nissan Titan AUTOMOBILES
DRIVESHAFT, Replace -> Front -> Rear
Vehicle: 2006 Nissan Titan XE 5.6 V8 FLEX
Front
- Place vehicle in neutral.
- Release parking brake.
- Raise and support vehicle and support it with safety stands in proper locations.
- Place reference mark on front driveline shaft flange yoke and companion flange of front final driveline. Paint is recommended for match marks. Never damage flange yoke and companion flange of front final drive.
- Remove bolts and then remove front driveline from front final drive and transfer case from vehicle.
- Reverse procedure to install, noting the following:
- Torque wheel lug nuts to 80 ft. lbs.
- Torque driveline to pinion flange bol...
CLICK HERE TO GET FULL ACCESS TO 2006 Nissan Titan DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2006 Nissan Titan AUTOMOBILES
Reset Procedures
Vehicle: 2006 Nissan Titan SE 5.6 V8 GAS
The Low Tire Pressure Warning lamp will illuminate briefly as a bulb check when the ignition switch is placed in the On position. This system uses radio frequency pressure sensors which monitor pressure in all 4 tires. When operating the vehicle at a speed above 25 mp...
CLICK HERE TO GET FULL ACCESS TO 2006 Nissan Titan TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2006 Nissan Titan AUTOMOBILES
Starter, Replace
Vehicle: 2006 Nissan Titan SE 5.6 V8 GAS
- Disconnect battery ground cable.
- Remove intake manifold.
- Partially drain engine coolant into clean container. Never drain coolant when engine is hot to avoid being scalded.
- Remove bolts using engine cover.
- Release fuel pressure.
- Remove air cleaner hose intake clamps, disconnect MAP sensor connector, and remove bolts securing housing assembly.
- Disconnect fuel tube quick connector on engine side.
- Remove fuel injector quick connector cap on engine side only.
- Install suitable tool on sleeve side facing quick connector. Avoid fire and sparks and prepare container with a cloth beforehand as ...
CLICK HERE TO GET FULL ACCESS TO 2006 Nissan Titan STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2006 Nissan Titan AUTOMOBILES
Cabin Air Filter Service -> Nissan -> 2005-06 Titan
Vehicle: 2006 Nissan Titan LE 5.6 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 12 months or 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove glove compartment two lower hinge pins, Fig. .
- Remove the glove compartment from the instrument panel and allow to hang from cord.
- Remove the cabin air filter cover screw, then the cabin air filter cover, Fig. .
- Remove cabin air filters from hea...
CLICK HERE TO GET FULL ACCESS TO 2006 Nissan Titan CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2006 Nissan Titan AUTOMOBILES
Nissan -> Automatic Transmission Oil Temperature Warning Lamp ->
Vehicle: 2006 Nissan Titan SE 5.6 V8 GAS
This lamp will be illuminated when the automatic transmission fluid temperature is excessive. When...
CLICK HERE TO GET FULL ACCESS TO 2006 Nissan Titan MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2006 Nissan Titan AUTOMOBILES
Radiator, Replace
Vehicle: 2006 Nissan Titan XE 5.6 V8 FLEX
- Drain engine coolant into a suitable container.
- Remove air intake duct and air cleaner assembly.
- Disconnect ATF cooler hoses at bottom of radiator. Plug lines to prevent leakage.
- Disconnect radiator upper and lower hoses from radiator, Fig. .
- Release tabs, then pull lower shroud rearward and out of vehicle.
- Remove u...
CLICK HERE TO GET FULL ACCESS TO 2006 Nissan Titan RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2006 Nissan Titan AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2006 Nissan Titan XE 5.6 V8 GAS
- Disconnect wiring harness connector from air cleaner case.
- Remove air cleaner duct and resonator assembly, then place air cleaner assembly aside.
- Rotate or lift belt te...
CLICK HERE TO GET FULL ACCESS TO 2006 Nissan Titan SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2006 Nissan Titan AUTOMOBILES
Component location diagrams for most 2006 Nissan Titan cars and light trucks sold in the U.S. from 1990+.
Electrical Units Locations Diagram for 2006 Nissan Titan LE 5.6 V8 FLEX Components on diagram: |
Rear Sonar System Diagram for 2006 Nissan Titan SE 5.6 V8 FLEX Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Nissan Titan PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2006 Nissan Titan AUTOMOBILES
OEM drawn wiring diagrams for most 2006 Nissan Titan cars and light trucks sold in the U.S.
2006 Nissan Titan SE 5.6 V8 GAS Wiring Diagram Components on diagram: |
2006 Nissan Titan LE 5.6 V8 FLEX Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Nissan Titan WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2006 Nissan Titan AUTOMOBILES
OEM TSB listings for most 2006 Nissan Titan cars and light trucks sold in the U.S. from 1985+.
Document: A/C SYSTEM O-RING SEAL LEAKS Vehicle: 2006 Nissan Titan LE 5.6 V8 GAS Auto Systems: |
Document: INTELLIGENT KEY / NATS KEY REGISTRATION PROCEDURES Vehicle: 2006 Nissan Titan LE 5.6 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2006 Nissan Titan TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2006 Nissan Titan AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2006 Nissan Titan cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2006 Nissan Titan cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2006 Nissan Titan cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2006 Nissan Titan cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2006 Nissan Titan SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2006 Nissan Titan vehicle. |
Access the Complete guide! |