Auto Parts Search
2006 Chevrolet Tahoe CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2006 Chevrolet Tahoe AUTOMOBILES
Power Brake Units -> Delco Brake Booster -> Power Brake Unit, Replace -> Astro, Avalanche, Escalade EXT, Safari, Sierra, Silverado & SSR -> Aztek & Rendezvous -> Blazer, Bravada, Envoy, Jimmy, Rainier & Trailblazer -> Canyon, Colorado, Sonoma & S10 -> Equinox & Torrent -> Escalade, HHR, Suburban, Tahoe & Yukon -> Express & Savana -> Hummer H2 -> Hummer H3 -> Montana, Silhouette & Venture -> Relay, Terraza, SV6 & Uplander -> SRX -> Vue
Vehicle: 2006 Chevrolet Tahoe 5.3 V8 GAS
Aztek & Rendezvous
- Remove coolant reservoir, then relieve fuel system pressure as follows:
- Loosen fuel filler cap to discharge tank pressure.
- Connect fuel pressure gauge tool No. J-34730-1A, or equivalent, to fuel pressure connection. Wrap shop towel around connection while connecting fuel pressure gauge in order to avoid fuel spillage.
- Install bleed hose into an approved container and open valve in order to bleed fuel system pressure.
- Drain any fuel remaining in fuel pressure gauge into suitable container.
- Remove cruise control cable from module, then disconnect electrical ...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Tahoe BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2006 Chevrolet Tahoe AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Pressure Relief -> Except Montana SV6, Relay, Rendezvous w/3.6L Engine, Terraza, Tracker & Uplander -> Engine Fuel Pressure Service Port -> Engines Less Fuel Pressure Service Port
Vehicle: 2006 Chevrolet Tahoe LS 4.8 V8 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the vehicle relearns its adaptive strategy.
Engines Less Fuel Pressure ...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Tahoe FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2006 Chevrolet Tahoe AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assemble -> Disassemble
Vehicle: 2006 Chevrolet Tahoe LS 5.3 V8 FLEX
Never clamp propeller shaft tubing in a vise. Clamping could dent or deform the tube causing an imbalance or unsafe condition. Always clamp on one of the yokes and support the shaft horizontally. Avoid damaging the slip yoke sealing surface. Nicks may damage the bushing or cut the lip seal.
Disassemble
- Support propeller shaft in a line horizontal with table of a press.
- Mark propeller shaft in order to show which end connects to transmission and which end goes to rear axle.
- On models equipped with external snap ring retainers, proceed as follows:
- Disassemble snap rings by ...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Tahoe DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2006 Chevrolet Tahoe AUTOMOBILES
Component Replacement -> Installation -> Removal -> Tire Pressure Indicator Sensor (Clamp Style) -> Tire Pressure Indicator Sensor (Snap In Style)
Vehicle: 2006 Chevrolet Tahoe 4.8 V8 GAS
Tire Pressure Indicator Sensor (Clamp Style)
Each tire pressure sensor has an internal power supply which has a service life of 10 years.
Removal
- Loosen the lug nuts.
- Raise and support vehicle with jack stands, then remove the wheel and tire assembly.
- Prior to dismounting the tire from the wheel, note the following precautions:
- Position the bead breaking fixture 90° from the valve stem when separating the tire bead from the wheel.
- Place the mounting and dismounting head so that the tire iron or pry bar can be inserted slightly clockwise of the sensor body when prying the tire bea...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Tahoe TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2006 Chevrolet Tahoe AUTOMOBILES
Starter, Replace
Vehicle: 2006 Chevrolet Tahoe 5.3 V8 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- Disconnect starter battery positive cable and wiring harness.
- Remove starter motor mounting bolts, washers, shims, starter and heat shield from vehicle.
- Rever...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Tahoe STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2006 Chevrolet Tahoe AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1999-2007 Silverado, Sierra, 2000-07 Denali, Suburban, Tahoe, Yukon, Yukon XL, 2001-07 Escalade & 2002-07 Avalanche
Vehicle: 2006 Chevrolet Tahoe 5.3 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the righthand instrument panel hush panel.
- Remove the A/C and heater modul...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Tahoe CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2006 Chevrolet Tahoe AUTOMOBILES
General Motors Corp./Saturn Trucks -> Tire Pressure Monitoring System (TPMS) Warning Indicator -> 2004-06 Tahoe -> Relearn -> Reset
Vehicle: 2006 Chevrolet Tahoe LT 5.3 V8 GAS
Reset
When the TPMS detects a significant loss of tire pressure, the CHECK TIRE PRESSURE message is displayed on the DIC and the low tire pressure indicator is displayed on the IPC. Adjusting tire to recommended pressure will clear the tire message.
Relearn
- Apply the Parking brake, then place the ignition switch in the On position.
- Cycle the headlamp switch from Off to Parking Lamp position 4 times within 4 seconds.
- The horn should chirp twice and the low tire pressure warning indicator should begin to flash indicating the system is in the learn mode.
- If GM tool No. J-46079 or equivalen...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Tahoe MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2006 Chevrolet Tahoe AUTOMOBILES
Radiator, Replace
Vehicle: 2006 Chevrolet Tahoe 4.8 V8 GAS
- Drain radiator coolant into suitable container.
- Remove upper and lower radiator hoses.
- Remove mounting bolts and lower fan shroud.
- Remove engine vent hose and surge take hose.
- Disconnect eng...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Tahoe RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2006 Chevrolet Tahoe AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2006 Chevrolet Tahoe 4.8 V8 GAS
- Rotate tensioner clockwise to release belt tension using suitable wrench, then remove belt.
- Route belt over pulleys excep...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Tahoe SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2006 Chevrolet Tahoe AUTOMOBILES
Component location diagrams for most 2006 Chevrolet Tahoe cars and light trucks sold in the U.S. from 1990+.
PCM Location Diagram for 2006 Chevrolet Tahoe Z71 5.3 V8 FLEX Components on diagram: |
Rear Overhead Console Diagram for 2006 Chevrolet Tahoe 4.8 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Tahoe PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2006 Chevrolet Tahoe AUTOMOBILES
OEM drawn wiring diagrams for most 2006 Chevrolet Tahoe cars and light trucks sold in the U.S.
2006 Chevrolet Tahoe 5.3 V8 GAS Wiring Diagram Components on diagram: |
2006 Chevrolet Tahoe LS 5.3 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Tahoe WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2006 Chevrolet Tahoe AUTOMOBILES
OEM TSB listings for most 2006 Chevrolet Tahoe cars and light trucks sold in the U.S. from 1985+.
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2006 Chevrolet Tahoe 4.8 V8 GAS Auto Systems: |
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2006 Chevrolet Tahoe 4.8 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Tahoe TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2006 Chevrolet Tahoe AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2006 Chevrolet Tahoe cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2006 Chevrolet Tahoe cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2006 Chevrolet Tahoe cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2006 Chevrolet Tahoe cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Tahoe SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2006 Chevrolet Tahoe vehicle. |
Access the Complete guide! |