Auto Parts Search
2006 Chevrolet Monte Carlo CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2006 Chevrolet Monte Carlo AUTOMOBILES
Disc Brakes -> AC-Delco Single Piston Rear Disc Brake -> Caliper Service -> All Models Except Century, Grand Prix & Regal -> Assemble -> Century, Grand Prix & Regal -> Disassemble -> Inspect -> Inspection -> Replacement
Vehicle: 2006 Chevrolet Monte Carlo LT 3.9 V6 GAS
All Models Except Century, Grand Prix & Regal
Replacement
- Raise and support vehicle.
- Mark wheel to axle flange relationship for installation alignment, then remove wheel and tire assembly.
- Remove brake hose from caliper. Plug openings in caliper and brake hose.
- Lift able spring to free end of from lever, then disconnect parking brake cable from lever.
- Remove cable support bracket mounting bolt and washer.
- Remove sleeve bolt and caliper.
- Reverse procedure to install, then bleed brakes.
Disassemble
- Pad interior of caliper assembly with clean shop towel, then remove piston assembly using low...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Monte Carlo BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2006 Chevrolet Monte Carlo AUTOMOBILES
General Motors Corp./Saturn Passenger Cars -> Fuel Pressure Relief -> Except Aveo, LaCrosse, LeMans (1988-93), Malibu & Malibu Maxx (2004-05), Metro, Nova, Prizm, Spectrum & Storm -> Engine Fuel Pressure Service Port -> Engines Less Fuel Pressure Service Port
Vehicle: 2006 Chevrolet Monte Carlo LT 3.9 V6 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the vehicle relearns its adaptive strateg...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Monte Carlo FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2006 Chevrolet Monte Carlo AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2006 Chevrolet Monte Carlo LT 3.5 V6 FLEX
- Raise and support vehicle on a hoist.
- Remove tire and wheel assembly.
- Disconnect tie rod from knuckle.
- Insert a drift into rotor and against caliper in order to prevent rotor from turning.
- Remove wheel drive shaft nut.
- Remove stabilizer link.
- Be sure that wheel speed sensor wiring harness is repositioned away from ball joint after disconnecting electrical connector from sensor. Disconnect ele...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Monte Carlo DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2006 Chevrolet Monte Carlo AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Diagnostic System Check -> Diagnostic Tests -> DTC C0569 System Configuration Error -> DTC C0750 Left Front Low Tire Pressure Sensor, C0755 Right Front Low Tire Pressure Sensor, C0760 Left Rear Low Tire Pressure Sensor Or C0765 Right Rear Low Tire Pressure Sensor -> DTC C0775 Low Tire Pressure System Sensors Not Learned -> Intermittent & Poor Connections -> Intermittents -> Low Tire Pressure Indicator Always On -> Low Tire Pressure Indicator Inoperative -> Poor Connections
Vehicle: 2006 Chevrolet Monte Carlo LS 3.5 V6 FLEX
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to Data Link Connector (DLC) and follow manufacturer's instructions.
Diagnostic Tests
Diagnostic System Check
- Inspect the vehicle for the installation of aftermarket devices which could affect the operation of the TPMS.
- Inspect the vehicle for damage or conditions which could cause the system to malfunction.
- Verify that the scan tool selected Front and Rear Tire Pressure parameters are correct when compared to the tires actual pressure ratings. If tire pressure parameters are not correct, use scan tool spec...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Monte Carlo TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2006 Chevrolet Monte Carlo AUTOMOBILES
Starter, Replace
Vehicle: 2006 Chevrolet Monte Carlo LT 3.9 V6 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- Remove radiator air deflector attaching screws and retainers, then air deflector.
- Remove torque converter cover attaching bolts and cover.
- Disconnect starter electrical connectors.
- Remove mounting bolt...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Monte Carlo STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2006 Chevrolet Monte Carlo AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 2004-08 Grand Prix, 2005-09 LaCrosse & 2006-07 Monte Carlo & 2006-09 Impala
Vehicle: 2006 Chevrolet Monte Carlo SS 5.3 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 12 months or 15,000 miles or at Maintenance II as indicated on the DIC (Driver Information Center). In dusty areas change the cabin air filter more often.
- Place the windshield wipers in the up position by turning the ignition switch Off when the wipers reach the desired position.
- Open the hood.
- Lift the righthand side of the rear hood seal from the flange in the area of the righthand air inlet grill...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Monte Carlo CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2006 Chevrolet Monte Carlo AUTOMOBILES
General Motors Corp./Saturn Cars -> Air Bag Warning Lamp ->
Vehicle: 2006 Chevrolet Monte Carlo LT 3.5 V6 FLEX
This lamp should light for a approximately 6-8 seconds when the ignition is turned on as a bulb check. If the air b...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Monte Carlo MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2006 Chevrolet Monte Carlo AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2006 Chevrolet Monte Carlo LS 3.5 V6 FLEX
Lower
- Raise and support vehicle.
- Drain cooling system into a suitable container.
- Reposition hose clamp from radiator using hose clamp pliers J 38185 or equivalent.
- Remove radiator outlet hose from radiator.
- Reposition hose clamp from engine using hose clamp pliers J 38185 or equivalent.
- Remove radiator outlet hose from engine and from vehicle.
- Reverse procedure to install.
...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Monte Carlo RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2006 Chevrolet Monte Carlo AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2006 Chevrolet Monte Carlo LT 3.5 V6 FLEX
- Lift or rotate tensioner using a 1/2 i...
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Monte Carlo SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2006 Chevrolet Monte Carlo AUTOMOBILES
Component location diagrams for most 2006 Chevrolet Monte Carlo cars and light trucks sold in the U.S. from 1990+.
Stop Lamp Diagram for 2006 Chevrolet Monte Carlo LT 3.5 V6 FLEX Components on diagram: |
Engine Compartment Diagram for 2006 Chevrolet Monte Carlo LS 3.5 V6 FLEX Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Monte Carlo PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2006 Chevrolet Monte Carlo AUTOMOBILES
OEM drawn wiring diagrams for most 2006 Chevrolet Monte Carlo cars and light trucks sold in the U.S.
2006 Chevrolet Monte Carlo LS 3.5 V6 FLEX Wiring Diagram Components on diagram: |
2006 Chevrolet Monte Carlo LS 3.5 V6 FLEX Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Monte Carlo WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2006 Chevrolet Monte Carlo AUTOMOBILES
OEM TSB listings for most 2006 Chevrolet Monte Carlo cars and light trucks sold in the U.S. from 1985+.
Document: Resistance in Steering with High Under hood Temperatures Vehicle: 2006 Chevrolet Monte Carlo LS 3.5 V6 GAS Auto Systems: |
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2006 Chevrolet Monte Carlo LS 3.5 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Monte Carlo TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2006 Chevrolet Monte Carlo AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2006 Chevrolet Monte Carlo cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2006 Chevrolet Monte Carlo cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2006 Chevrolet Monte Carlo cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2006 Chevrolet Monte Carlo cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Monte Carlo SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2006 Chevrolet Monte Carlo vehicle. |
Access the Complete guide! |