Auto Parts Search
2005 Pontiac Grand Prix CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Pontiac REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2005 Pontiac Grand Prix AUTOMOBILES
Hydraulic Brake Systems -> Troubleshooting -> Master Cylinder Internal Fluid Leakage Check -> Road Test
Vehicle: 2005 Pontiac Grand Prix 3.8 V6 GAS
When troubleshooting the hydraulic brake system, perform the following inspections.
Master Cylinder Internal Fluid Leakage Check
Start engine and depress the brake pedal. If the pedal gradually falls under constant pressure, the hydraulic system may be leaking. Raise the vehicle on a lift and inspect all tubing lines and backing plates for signs of leakage. It may be required to lift or remove the carpeting or floor mats to inspect for boost...
CLICK HERE TO GET FULL ACCESS TO 2005 Pontiac Grand Prix BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2005 Pontiac Grand Prix AUTOMOBILES
General Motors Corp./Saturn Passenger Cars -> Fuel Filter Scheduled Maintenance -> 1980-06 Gasoline Engine Models Except Catera, LeMans (1988-93) Metro, Nova (1985-88), Saturn & Sprint -> Normal Service -> Severe Service
Vehicle: 2005 Pontiac Grand Prix GXP 5.3 V8 GAS
CLICK HERE TO GET FULL ACCESS TO 2005 Pontiac Grand Prix FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2005 Pontiac Grand Prix AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2005 Pontiac Grand Prix GXP 5.3 V8 GAS
To avoid any vehicle damage, serious personal injury or death when major components are removed from the vehicle and the vehicle is supported by a hoist, support the vehicle with jack stands at the opposite end from which the components are being removed and strap the vehicle to the hoist.
- Raise and support vehicle on a hoist.
- Remove rear tire and wheel assembly.
- Remove wheel drive shaft retaining nut and discard the nut.
- Disconnect wheel speed sensor electrical connector.
- Detach wheel speed sensor wiring harness mounting clip from knuckle.
- Detach rear park brake cable and clev...
CLICK HERE TO GET FULL ACCESS TO 2005 Pontiac Grand Prix DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2005 Pontiac Grand Prix AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Intermittent & Poor Connections -> Intermittent Connections -> Poor Connections -> Scan Tool Data Definitions
Vehicle: 2005 Pontiac Grand Prix 3.8 V6 GAS
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Link Connector) and follow manufacturer's instructions.
Scan Tool Data Definitions
Refer to Fig. for scan tool data definitions.
Clearing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Link Connector), and follow manufacturer's instructions.
Intermittent & Poor Connections
Intermittent Connections
Most intermittent connections are caused by faulty electrical connections or wiring. Inspect for the following:
- Wiring broken inside insulation.
- Poor connection between male and fema...
CLICK HERE TO GET FULL ACCESS TO 2005 Pontiac Grand Prix TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2005 Pontiac Grand Prix AUTOMOBILES
Starter, Replace
Vehicle: 2005 Pontiac Grand Prix GXP 5.3 V8 GAS
- Disconnect battery ground cable.
- Remove starter solenoid BAT terminal nut and positive battery cable from starter motor.
- Remove engine harness terminal from starter motor.
- Disconnect starter motor elect...
CLICK HERE TO GET FULL ACCESS TO 2005 Pontiac Grand Prix STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2005 Pontiac Grand Prix AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 2004-08 Grand Prix, 2005-09 LaCrosse & 2006-07 Monte Carlo & 2006-09 Impala
Vehicle: 2005 Pontiac Grand Prix 3.8 V6 GAS
Under normal operating conditions the cabin air filter should be replaced every 12 months or 15,000 miles or at Maintenance II as indicated on the DIC (Driver Information Center). In dusty areas change the cabin air filter more often.
- Place the windshield wipers in the up position by turning the ignition switch Off when the wipers reach the desired position.
- Open the hood.
- Lift the righthand side of the rear hood seal from the flange in the area of the righthand air inlet grill...
CLICK HERE TO GET FULL ACCESS TO 2005 Pontiac Grand Prix CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2005 Pontiac Grand Prix AUTOMOBILES
General Motors Corp./Saturn Cars -> Low Coolant Lamp ->
Vehicle: 2005 Pontiac Grand Prix 3.8 V6 GAS
This lamp should light when engine coolant level in the radiator drops below a predetermined le...
CLICK HERE TO GET FULL ACCESS TO 2005 Pontiac Grand Prix MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2005 Pontiac Grand Prix AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2005 Pontiac Grand Prix 3.8 V6 GAS
Lower
- Drain cooling system into a suitable container.
- Reposition hose clamp from water pump housing using hose clamp pliers J 38185 or equivalent.
- Remove radiator outlet hose from water pump housing.
- Remove lower radiator air deflector.
- Reposition hose clamp from radiator using hose clamp pliers J 38185 or equivalent.
- Remove radiator outlet hose from radiator and from vehicle.
- Re...
CLICK HERE TO GET FULL ACCESS TO 2005 Pontiac Grand Prix RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2005 Pontiac Grand Prix AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2005 Pontiac Grand Prix GTP 3.8 V6 GAS
- Remove the battery.
- Rotate the tensioner counterclockwise to remove the drive belt.
- Remove the supercharger belt from...
CLICK HERE TO GET FULL ACCESS TO 2005 Pontiac Grand Prix SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2005 Pontiac Grand Prix AUTOMOBILES
Component location diagrams for most 2005 Pontiac Grand Prix cars and light trucks sold in the U.S. from 1990+.
Left Side Of Rear Compartment Diagram for 2005 Pontiac Grand Prix GTP 3.8 V6 GAS Components on diagram: |
Lower Right Side of the Engine Diagram for 2005 Pontiac Grand Prix GXP 5.3 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Pontiac Grand Prix PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2005 Pontiac Grand Prix AUTOMOBILES
OEM drawn wiring diagrams for most 2005 Pontiac Grand Prix cars and light trucks sold in the U.S.
2005 Pontiac Grand Prix 3.8 V6 GAS Wiring Diagram Components on diagram: |
2005 Pontiac Grand Prix GTP 3.8 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Pontiac Grand Prix WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2005 Pontiac Grand Prix AUTOMOBILES
OEM TSB listings for most 2005 Pontiac Grand Prix cars and light trucks sold in the U.S. from 1985+.
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2005 Pontiac Grand Prix 3.8 V6 GAS Auto Systems: |
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2005 Pontiac Grand Prix 3.8 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2005 Pontiac Grand Prix TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2005 Pontiac Grand Prix AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2005 Pontiac Grand Prix cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2005 Pontiac Grand Prix cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2005 Pontiac Grand Prix cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2005 Pontiac Grand Prix cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2005 Pontiac Grand Prix SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2005 Pontiac Grand Prix vehicle. |
Access the Complete guide! |