Auto Parts Search
2005 Mercury Montego CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Mercury REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2005 Mercury Montego AUTOMOBILES
Hydraulic Brake Systems -> Hydraulic Brake System Flush
Vehicle: 2005 Mercury Montego 3.0 V6 GAS
Whenever new brake components are installed in the hydraulic system, it is recommended that the entire hydraulic system be thoroughly flushed with clean brake fluid.
It may sometime become required to flush out the system due to the presence of mineral oil, kerosene, gasoline, etc., which will cause swelling of rubber piston cups and valves and render them inoperative.
Flushing is performed at e...
CLICK HERE TO GET FULL ACCESS TO 2005 Mercury Montego BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2005 Mercury Montego AUTOMOBILES
Ford Motor Co. Passenger Cars -> Fuel Shutoff Switch Location -> Five Hundred & Montego
Vehicle: 2005 Mercury Montego 3.0 V6 GAS
The inertia switch i...
CLICK HERE TO GET FULL ACCESS TO 2005 Mercury Montego FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2005 Mercury Montego AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 2005 Mercury Montego 3.0 V6 GAS
Failure to correctly index-mark driveshaft will lead to noise, vibration or harshness (NVH) problems. Index-mark driveshaft to rear axle pinion flange, power take off (PTO) flange and center bearing bracket. Index-mark driveshaft.
- With vehicle in NEUTRAL, raise and support vehicle.
- Remove exhaust system at flex pipe.
- Remove exhaust support brace bolts, then exhaust support brace.
- Always install new drivesh...
CLICK HERE TO GET FULL ACCESS TO 2005 Mercury Montego DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2005 Mercury Montego AUTOMOBILES
Starter, Replace
Vehicle: 2005 Mercury Montego 3.0 V6 GAS
The heavy gauge input lead connected to starter solenoid is hot at all times. Ensure protective cap is installed over terminal and is replaced after service.
- Disconnect battery ground cable.
- Raise and support vehicle.
- Remove lower air deflec...
CLICK HERE TO GET FULL ACCESS TO 2005 Mercury Montego STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2005 Mercury Montego AUTOMOBILES
Ford Motor Co. Cars -> Air Bag Warning Lamp ->
Vehicle: 2005 Mercury Montego 3.0 V6 GAS
This lamp should light for a approximately 6-8 seconds when the ignition is turned On as a bulb check. If the Air B...
CLICK HERE TO GET FULL ACCESS TO 2005 Mercury Montego MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2005 Mercury Montego AUTOMOBILES
Radiator, Replace
Vehicle: 2005 Mercury Montego 3.0 V6 GAS
- Drain cooling system into suitable container.
- Remove battery and battery tray.
- Disconnect upper radiator hose.
- Disconnect degas bottle return hose.
- Disconnect upper transaxle cooler line using suitable disconnect tool.
- Remove air conditioning condenser mounting bolts.
- Raise a...
CLICK HERE TO GET FULL ACCESS TO 2005 Mercury Montego RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2005 Mercury Montego AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2005 Mercury Montego 3.0 V6 GAS
- Remove accessory drive belt splash shield.
- Rotate drive belt tensioner...
CLICK HERE TO GET FULL ACCESS TO 2005 Mercury Montego SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2005 Mercury Montego AUTOMOBILES
Component location diagrams for most 2005 Mercury Montego cars and light trucks sold in the U.S. from 1990+.
Driver Door Diagram for 2005 Mercury Montego 3.0 V6 GAS Components on diagram: |
Left Front Diagram for 2005 Mercury Montego 3.0 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Mercury Montego PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2005 Mercury Montego AUTOMOBILES
OEM drawn wiring diagrams for most 2005 Mercury Montego cars and light trucks sold in the U.S.
2005 Mercury Montego 3.0 V6 GAS Wiring Diagram Components on diagram: |
2005 Mercury Montego 3.0 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Mercury Montego WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2005 Mercury Montego AUTOMOBILES
OEM TSB listings for most 2005 Mercury Montego cars and light trucks sold in the U.S. from 1985+.
Document: INOPERATIVE HEATED SEATS Vehicle: 2005 Mercury Montego 3.0 V6 GAS Symptoms: |
Document: TRANSMISSION HARD SHIFTING - NO DTCS - MILEAGE ABOVE 20,000 MILES - REVISED Vehicle: 2005 Mercury Montego 3.0 V6 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO 2005 Mercury Montego TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2005 Mercury Montego AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2005 Mercury Montego cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2005 Mercury Montego cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2005 Mercury Montego cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2005 Mercury Montego cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2005 Mercury Montego SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2005 Mercury Montego vehicle. |
Access the Complete guide! |