Auto Parts Search
2005 Chevrolet Silverado CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2005 Chevrolet Silverado AUTOMOBILES
Power Brake Units -> Delco Brake Booster -> Power Brake Unit, Replace -> Astro, Avalanche, Escalade EXT, Safari, Sierra, Silverado & SSR -> Aztek & Rendezvous -> Blazer, Bravada, Envoy, Jimmy, Rainier & Trailblazer -> Canyon, Colorado, Sonoma & S10 -> Equinox & Torrent -> Escalade, HHR, Suburban, Tahoe & Yukon -> Express & Savana -> Hummer H2 -> Hummer H3 -> Montana, Silhouette & Venture -> Relay, Terraza, SV6 & Uplander -> SRX -> Vue
Vehicle: 2005 Chevrolet Silverado SS 6.0 V8 GAS
Aztek & Rendezvous
- Remove coolant reservoir, then relieve fuel system pressure as follows:
- Loosen fuel filler cap to discharge tank pressure.
- Connect fuel pressure gauge tool No. J-34730-1A, or equivalent, to fuel pressure connection. Wrap shop towel around connection while connecting fuel pressure gauge in order to avoid fuel spillage.
- Install bleed hose into an approved container and open valve in order to bleed fuel system pressure.
- Drain any fuel remaining in fuel pressure gauge into suitable container.
- Remove cruise control cable from module, then disconnect electrical ...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Silverado BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2005 Chevrolet Silverado AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Component Locations -> 1999-06 Silverado & Sierra
Vehicle: 2005 Chevrolet Silverado SS 6.0 V8 GAS
Refer ...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Silverado FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2005 Chevrolet Silverado AUTOMOBILES
DRIVESHAFT, Replace -> Front -> Rear
Vehicle: 2005 Chevrolet Silverado SS 6.0 V8 GAS
Front
Before disassembly, observe and accurately reference mark all driveline components relative to the propeller shaft and axles. These items include the propeller shafts, wheel drive shafts, pinion flanges and output shafts
Assemble all components in the exact relationship to each other as they were prior to removal. Observe all published specifications and torque values, and any measurements obtained prior to disassembly.
- Raise and support vehicle.
- Remove transfer case shield, if equipped.
- If equipped with double clamp style boot, remove clamp at transfer case by prying up ex...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Silverado DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2005 Chevrolet Silverado AUTOMOBILES
Alternator, Replace
Vehicle: 2005 Chevrolet Silverado SS 6.0 V8 GAS
- Disconnect battery ground cable.
- Remove air inlet duct, if required.
- Disconnect terminal plug and battery lead connections from back of alternator.
- Remove upper fan shroud mounting bolts and fan shroud.
- Remove accessory drive belt using suitable 3/8 i...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Silverado STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2005 Chevrolet Silverado AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1999-2007 Silverado, Sierra, 2000-07 Denali, Suburban, Tahoe, Yukon, Yukon XL, 2001-07 Escalade & 2002-07 Avalanche
Vehicle: 2005 Chevrolet Silverado SS 6.0 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the righthand instrument panel hush panel.
- Remove the A/C and heater modul...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Silverado CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2005 Chevrolet Silverado AUTOMOBILES
General Motors Corp./Saturn Trucks -> Reduce Engine Power Indicator Lamp ->
Vehicle: 2005 Chevrolet Silverado SS 6.0 V8 GAS
The Reduce Engine Power indicator lamp should light for a approximately 3 seconds when the ignition is turned On as a bulb check. If the warning lamp turns On during vehicle operation, a vehicl...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Silverado MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2005 Chevrolet Silverado AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2005 Chevrolet Silverado SS 6.0 V8 GAS
Inlet
- Drain cooling system into a suitable container.
- Remove air intake tube.
- Remove heater and surge tank hose from mounting clip.
- Reposition heater core inlet hose clamp at engine coolant inlet fitting.
- Remove hose from engine coolant inlet fitting.
- Reposition heater hose inlet clamp at heater core.
- Remove heater inlet hose from ...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Silverado RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2005 Chevrolet Silverado AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2005 Chevrolet Silverado SS 6.0 V8 GAS
- Rotate tensioner clockwise to release belt tension using suitable wrench, then remove belt.
- Route belt over pulleys excep...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Silverado SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2005 Chevrolet Silverado AUTOMOBILES
Component location diagrams for most 2005 Chevrolet Silverado cars and light trucks sold in the U.S. from 1990+.
Manual Transmission Diagram for 2005 Chevrolet Silverado SS 6.0 V8 GAS Components on diagram: |
Auxiliary Battery Relay Diagram for 2005 Chevrolet Silverado SS 6.0 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Silverado PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2005 Chevrolet Silverado AUTOMOBILES
OEM drawn wiring diagrams for most 2005 Chevrolet Silverado cars and light trucks sold in the U.S.
2005 Chevrolet Silverado SS 6.0 V8 GAS Wiring Diagram Components on diagram: |
2005 Chevrolet Silverado SS 6.0 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Silverado WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2005 Chevrolet Silverado AUTOMOBILES
OEM TSB listings for most 2005 Chevrolet Silverado cars and light trucks sold in the U.S. from 1985+.
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2005 Chevrolet Silverado SS 6.0 V8 GAS Auto Systems: |
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2005 Chevrolet Silverado SS 6.0 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Silverado TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2005 Chevrolet Silverado AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2005 Chevrolet Silverado cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2005 Chevrolet Silverado cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2005 Chevrolet Silverado cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2005 Chevrolet Silverado cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Silverado SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2005 Chevrolet Silverado vehicle. |
Access the Complete guide! |