Auto Parts Search
2004 Cadillac Deville CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Cadillac REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2004 Cadillac Deville AUTOMOBILES
Air Bag System Precautions -> General Motors Corp. -> Arming -> Light Trucks & Vans -> Passenger Cars
Vehicle: 2004 Cadillac Deville DHS 4.6 V8 GAS
Passenger Cars
Reverse disarming procedures to arm the Supplemental Restraint System, noting the following:
- Ensure all disconnected SRS electrical connectors are securely connected and routed.
- Install all removed fuses in proper locations.
- From a safe position at sides of or below air bag module, Turn ignition switch to ON position and observe Air Bag or SRS warning lamp.
- On all models except Prizm and 1990 Corvette, warning lamp should flash seven to nine times, then go off.
- On Prizm models, warning lamp should light for six seconds,...
CLICK HERE TO GET FULL ACCESS TO 2004 Cadillac Deville A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2004 Cadillac Deville AUTOMOBILES
Hydraulic Brake Systems -> Hydraulic Brake System Flush
Vehicle: 2004 Cadillac Deville DTS 4.6 V8 GAS
If brake fluid is old, rusty or contaminated or whenever new components are installed in hydraulic system, the system must be flushed. Bleed brakes...
CLICK HERE TO GET FULL ACCESS TO 2004 Cadillac Deville BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2004 Cadillac Deville AUTOMOBILES
General Motors Corp./Saturn Passenger Cars -> Fuel Filter Scheduled Maintenance -> 1980-06 Gasoline Engine Models Except Catera, LeMans (1988-93) Metro, Nova (1985-88), Saturn & Sprint -> Normal Service -> Severe Service
Vehicle: 2004 Cadillac Deville 4.6 V8 GAS
CLICK HERE TO GET FULL ACCESS TO 2004 Cadillac Deville FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2004 Cadillac Deville AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2004 Cadillac Deville DHS 4.6 V8 GAS
- Raise and support vehicle.
- Remove tire and wheel assembly.
- On models with road sensing suspension, disconnect level sensor link from ball stud on lower control arm.
- On all models, disconnect outer tie rod end from steering knuckle. Do not loosen tie rod end jam nut.
- Insert a drift or punch into brake rotor and against caliper in order to prevent wheel hub and bearing from turning.
- Remove and discard wheel drive shaft spindle nut.
- Remove stabilizer shaft link.
- Disconnect electrical connector from wheel speed sensor and reposition wiring harness away from ball joint.Be sure that w...
CLICK HERE TO GET FULL ACCESS TO 2004 Cadillac Deville DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2004 Cadillac Deville AUTOMOBILES
Wiring Diagrams -> Wire Color Code Identification
Vehicle: 2004 Cadillac Deville 4.6 V8 GAS
Refer to Figs. and for wir...
[[table data]]CLICK HERE TO GET FULL ACCESS TO 2004 Cadillac Deville TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2004 Cadillac Deville AUTOMOBILES
Alternator, Replace
Vehicle: 2004 Cadillac Deville DTS 4.6 V8 GAS
- Disconnect battery ground cable.
- Mark belt running direction.
- Rotate drive belt tensioner mechanism upward and away from drive belt using suitable 1/2 inch breaker bar.
- Remove serpentine drive belt.
- Disconnect a...
CLICK HERE TO GET FULL ACCESS TO 2004 Cadillac Deville STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2004 Cadillac Deville AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 2000-05 DeVille
Vehicle: 2004 Cadillac Deville DTS 4.6 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 12 months or 15,000 miles. In dusty areas change the cabin air filter more often.
- Open the hood.
- Remove the cabin air filter access cover from the righthand side of the cowl panel, On 2000 models, use a suitable screwdriver to pry up the access cover. On 2001-05 models, press the tabs to release...
CLICK HERE TO GET FULL ACCESS TO 2004 Cadillac Deville CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2004 Cadillac Deville AUTOMOBILES
General Motors Corp./Saturn Cars -> Check Gauge Warning Lamp ->
Vehicle: 2004 Cadillac Deville DTS 4.6 V8 GAS
The Check Gauge warning lamp will light to warn the driver to inspect the oil pressure gauge, engine coolant temperature ga...
CLICK HERE TO GET FULL ACCESS TO 2004 Cadillac Deville MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2004 Cadillac Deville AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2004 Cadillac Deville 4.6 V8 GAS
Inlet
- Drain cooling system into a suitable container.
- Raise and support vehicle. A mirror is needed to see bolt, which is located next to engine at base of head and at top of transmission bell house.
- Remove lower bolt from heater pipe assembly at thermostat assembly.
- Lower vehicle.
- Remove cover assembly to engine intake manifold.
- Remove battery tray.
- Remove lower bolt securing battery tray to panel assembly on front air inlet housing.
- Remove nuts securing panel assembly to front of dash.
- Remove panel assembly from vehicle.
- Reposition heater hose inlet clamp at heater pipe using hose ...
CLICK HERE TO GET FULL ACCESS TO 2004 Cadillac Deville RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2004 Cadillac Deville AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2004 Cadillac Deville DTS 4.6 V8 GAS
- Mark running direction, if belt is to be reused.
- Rotate drive belt tensioner mechanism upward and away from drive belt us...
CLICK HERE TO GET FULL ACCESS TO 2004 Cadillac Deville SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2004 Cadillac Deville AUTOMOBILES
Component location diagrams for most 2004 Cadillac Deville cars and light trucks sold in the U.S. from 1990+.
Right Rear Of The Passenger Compartment, Behind The Rear Seat Back Diagram for 2004 Cadillac Deville DHS 4.6 V8 GAS Components on diagram: |
Park Brake System Component Views Diagram for 2004 Cadillac Deville DTS 4.6 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2004 Cadillac Deville PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2004 Cadillac Deville AUTOMOBILES
OEM drawn wiring diagrams for most 2004 Cadillac Deville cars and light trucks sold in the U.S.
2004 Cadillac Deville DTS 4.6 V8 GAS Wiring Diagram Components on diagram: |
2004 Cadillac Deville DTS 4.6 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2004 Cadillac Deville WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2004 Cadillac Deville AUTOMOBILES
OEM TSB listings for most 2004 Cadillac Deville cars and light trucks sold in the U.S. from 1985+.
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2004 Cadillac Deville 4.6 V8 GAS Auto Systems: |
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 2004 Cadillac Deville 4.6 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2004 Cadillac Deville TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2004 Cadillac Deville AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2004 Cadillac Deville cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2004 Cadillac Deville cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2004 Cadillac Deville cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2004 Cadillac Deville cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2004 Cadillac Deville SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2004 Cadillac Deville vehicle. |
Access the Complete guide! |