Auto Parts Search
2002 Lincoln LS CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Lincoln REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2002 Lincoln LS car and truck
repair procedures including Lincoln engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Lincoln LS automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 2002 Lincoln LS AUTOMOBILES
Air Bag System Precautions -> Ford Motor Co. -> Disarming -> 1990-91 -> 1990-92 -> 1991-92 -> 1992-93 -> 1992-94 -> 1992-96 -> 1993 -> 1993-94 -> 1993-95 -> 1994 -> 1994-95 -> 1994-97 -> 1995-2000 -> 1995-2004 -> 1995-96 -> 1995-97 -> 1995-98 -> 1996-97 -> 1996-99 -> 1997-2000 -> 1997-2001 -> 1997-2004 -> 1997-99 -> 1998 -> 1998-2000 -> 1998-2002 -> 1999-2000 -> 1999-2001 -> 1999-2002 -> 1999-2004 -> 2000 -> 2000-01 -> 2000-04 -> 2001-02 -> 2001-03 -> 2001-04 -> 2002-03 -> 2002-04 -> 2004 -> Aerostar & Bronco -> Aspire -> Aviator -> Blackwood, Expedition & Navigator -> Built After February 2002 -> Built Before March 2002 -> Capri -> Continental -> Contour & Mystique -> Cougar -> Crown Victoria, Grand Marquis & Marauder -> Econoline -> Escape -> Escort, Tracer & ZX2 -> Excursion -> Explorer & Mountaineer -> Explorer Sport & Sport Trac -> F Series -> Focus -> Freestar & Monterey -> Light Trucks & Vans -> LS -> Mark VII -> Mark VIII -> Mustang -> Passenger Cars -> Probe -> Ranger -> Sable & Taurus -> Tempo & Topaz -> Thunderbird -> Town Car -> Villager -> Windstar
Vehicle: 2002 Lincoln LS 3.0 V6 GAS
Passenger Cars
Prior to disconnecting battery, record preset radio frequencies.
After the battery has been disconnected and connected again, abnormal drive conditions may be present while the powertrain control module relearns its adaptive strategy. The vehicle may need to be driven 10 miles or more to relearn the strategy.
Aspire
- Disconnect battery ground cable and isolate.
- Wait one minute for back-up power supply to deplete stored energy.
- Remove four driver's side air bag module mounting bolts.
- Disconnect driver's side air bag module...
CLICK HERE TO GET FULL ACCESS TO 2002 Lincoln LS A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Lincoln LS AUTOMOBILES
Disc Brakes -> Front Disc Brakes -> Brake Pad Service -> Continental, Cougar, Crown Victoria, Grand Marquis, LS, Marauder, Mustang (Except Cobra), Sable, Taurus, Thunderbird & Town Car -> Contour & Mystique -> Escort, Tracer & ZX2 -> Focus -> Inspection -> Installation -> Mustang Cobra -> Removal
Vehicle: 2002 Lincoln LS 3.9 V8 GAS
On models with anti-lock brakes, the brake hydraulic system must be depressurized before disconnecting any hydraulic lines or fittings. Depressurize the system by pumping the brake pedal a minimum of 25 times with the ignition in the Off position.
Continental, Cougar, Crown Victoria, Grand Marquis, LS, Marauder, Mustang (Except Cobra), Sable, Taurus, Thunderbird & Town Car
Removal
- Remove brake fluid until reservoir is half full.
- On models equipped with air suspension, turn air suspension service switch to Off position.
- On all models, raise and support front of vehicle, then remove ...
CLICK HERE TO GET FULL ACCESS TO 2002 Lincoln LS BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2002 Lincoln LS AUTOMOBILES
Ford Motor Co. Passenger Cars -> Fuel Filter Replacement -> 2000-06 LS & 2002-05 Thunderbird -> Installation -> Removal
Vehicle: 2002 Lincoln LS 3.0 V6 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
When installing the fuel filter, ensure the flow arrow is facing in the proper direction.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven 10 miles or more while it relearns ...
CLICK HERE TO GET FULL ACCESS TO 2002 Lincoln LS FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2002 Lincoln LS AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 2002 Lincoln LS 3.9 V8 GAS
- Raise and support vehicle.
- Remove muffler and extension pipe, then the body brace.
- Remove heat shield.
- Inspect and record driveline angles.
- Place reference marks on bolts, washers, nuts and flex coupling to transmission flange and pinion flange for installation alignment.
- Remove driveshaft to axle flange mounting nuts. Do not remove flex coupling to driveshaft mounting bolts, Fig. .
- Loosen driveshaft length adjustment nut using driveshaft coupler wrenches, tool No. 205-474, or equivalents.
- Remove transmission flange to driveshaft mounting nuts. Do not remove flex coupling t...
CLICK HERE TO GET FULL ACCESS TO 2002 Lincoln LS DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2002 Lincoln LS AUTOMOBILES
Alternator, Replace
Vehicle: 2002 Lincoln LS 3.0 V6 GAS
- Disconnect battery ground cable.
- Remove accessory drive belt.
- Raise and support vehicle.
- Remove lower splash shield.
- Support alternator, then remove alternator mounting bolts.
- Disconnect alternator ...
CLICK HERE TO GET FULL ACCESS TO 2002 Lincoln LS STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2002 Lincoln LS AUTOMOBILES
Cabin Air Filter Service -> Ford Motor Co. -> 2002-06 LS
Vehicle: 2002 Lincoln LS 3.9 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Open the hood.
- Remove the pin type retainers attaching the passenger side cowl cover to the cowl.
- Detach the rubber hinge cover from rear outer corner of the passenger side cowl cover.
- Pull up on passenger side cowl cover to release the lower retaining clips, then remove the cover.
- Release the right...
CLICK HERE TO GET FULL ACCESS TO 2002 Lincoln LS CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2002 Lincoln LS AUTOMOBILES
Ford Motor Co. Cars -> Low Coolant Lamp ->
Vehicle: 2002 Lincoln LS 3.9 V8 GAS
The low coolant warning lamp should light whenever the coolant level in the coolant recovery bottle is 1/4 to 3/4 inch or more below the cold full mark. Raise coolant level in recovery bottle to the cold full mark to turn lamp off.
On models equipped with GEM module and low coolant level warning system, t...
CLICK HERE TO GET FULL ACCESS TO 2002 Lincoln LS MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2002 Lincoln LS AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2002 Lincoln LS 3.9 V8 GAS
Inlet
Two inlet hoses are used on this vehicle, using same removal procedure for both.
- Drain cooling system into a suitable container.
- Reposition heater hose inlet clamp at heater core.
- Remove heater inlet hose from heater core.
- Reposition heater core inlet hose clamp at coolant control valve.
- Remove hose from coolant control valve.
- Remove h...
CLICK HERE TO GET FULL ACCESS TO 2002 Lincoln LS RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2002 Lincoln LS AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2002 Lincoln LS 3.9 V8 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 2002 Lincoln LS SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2002 Lincoln LS AUTOMOBILES
Component location diagrams for most 2002 Lincoln LS cars and light trucks sold in the U.S. from 1990+.
 In Roof Diagram for 2002 Lincoln LS 3.9 V8 GASComponents on diagram: |
 Passenger Seat Diagram for 2002 Lincoln LS 3.0 V6 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Lincoln LS PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2002 Lincoln LS AUTOMOBILES
OEM drawn wiring diagrams for most 2002 Lincoln LS cars and light trucks sold in the U.S.
 2002 Lincoln LS 3.9 V8 GAS Wiring DiagramComponents on diagram: |
 2002 Lincoln LS 3.9 V8 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Lincoln LS WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2002 Lincoln LS AUTOMOBILES
OEM TSB listings for most 2002 Lincoln LS cars and light trucks sold in the U.S. from 1985+.
|
Document: ACCESSORY DRIVE BELT SNAP NOISE IN FREEZING TEMPERATURES Vehicle: 2002 Lincoln LS 3.9 V8 GAS Symptoms: |
|
Document: RECALL - CERTAIN 1992-2003 MODEL YEAR CARS AND TRUCKS - FUSED JUMPER HARNESS REPLACEMENT FOR VEHICLES SERVICED WITH AN INCOMPATIBLE FUSED JUMPER HARNESS Vehicle: 2002 Lincoln LS 3.0 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2002 Lincoln LS TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2002 Lincoln LS AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2002 Lincoln LS cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2002 Lincoln LS cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2002 Lincoln LS cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2002 Lincoln LS cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2002 Lincoln LS SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2002 Lincoln LS vehicle.
|
| Access the Complete guide! |
