Auto Parts Search
2002 Cadillac Seville CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Cadillac REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2002 Cadillac Seville AUTOMOBILES
Manual Air Conditioning & Heater System Diagnosis & Testing -> Passenger Cars -> Component Diagnosis & Testing -> Blower Motor -> Control Panel
Vehicle: 2002 Cadillac Seville SLS 4.6 V8 GAS
Blower Motor
Refer to "Diagnostic Tests" and for blower motor diagnosis an...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Seville A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Cadillac Seville AUTOMOBILES
Disc Brakes -> AC-Delco Single Piston Front Disc Brake -> Troubleshooting -> Brake Roughness
Vehicle: 2002 Cadillac Seville SLS 4.6 V8 GAS
Brake Roughness
The most common cause of brake chatter on disc brakes is a variation in disc thickness. If roughness or vibration is encountered during highway operation or if pedal pulsation is experienced at low speeds, the disc may have excessive thickness variation. To inspect for this condition, measure the disc at 12 points with a micrometer at a radius approximately one inch from edge of disc. If thickness measurements vary by more than ...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Seville BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2002 Cadillac Seville AUTOMOBILES
General Motors Corp./Saturn Passenger Cars -> Fuel Filter Scheduled Maintenance -> 1980-06 Gasoline Engine Models Except Catera, LeMans (1988-93) Metro, Nova (1985-88), Saturn & Sprint -> Normal Service -> Severe Service
Vehicle: 2002 Cadillac Seville SLS 4.6 V8 GAS
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Seville FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2002 Cadillac Seville AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2002 Cadillac Seville SLS 4.6 V8 GAS
- Raise vehicle and suitably support.
- Remove wheel and tire.
- Loosen or remove stabilizer shaft link assembly bolt as needed.
- Remove ball joint cotter pin and nut. Do not attempt to free ball stud by using a pickle fork or wedge type tool, because seal or bushing damage could result. Use the proper tool to separate all ball joints.
- With the pry bar between suspension support and lower control arm, separate joint.
- Remove hub nut. Insert a drift or screwdriver into caliper and rotor to prevent rotor from turning.
- Disconnect axle from hub using a suitable tool. The hub ...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Seville DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2002 Cadillac Seville AUTOMOBILES
Component Replacement -> Installation -> Removal -> Tire Pressure Indicator Sensor
Vehicle: 2002 Cadillac Seville STS 4.6 V8 GAS
Tire Pressure Indicator Sensor
Removal
- Loosen the lug nuts.
- Raise and support vehicle with jack stands, then remove the wheel and tire assembly.
- Prior to dismounting the tire from the wheel, note the following precautions:
- Position the bead breaking fixture 90° from the valve stem when separating the tire bead from the wheel.
- Place the mounting and dismounting head so that the tire iron or pry bar can be inserted slightly clockwise of the sensor body when prying the tire bead up and over the head.
- Rotate the tire and wheel assembly clockwise using the tire changer when transferri...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Seville TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2002 Cadillac Seville AUTOMOBILES
Starter, Replace
Vehicle: 2002 Cadillac Seville STS 4.6 V8 GAS
- Disconnect battery ground cable.
- Remove intake manifold.
- Disconnect starter S-terminal wire and battery cable.
- Remove mounting bolts and starter.
- Remove solenoid and battery cab...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Seville STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2002 Cadillac Seville AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1997-2004 Seville
Vehicle: 2002 Cadillac Seville STS 4.6 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Place the ignition switch in the Off position, then remove the SIR (Supplemental Inflatable Restraint) fuse from the rear fuse panel. On 1997 models, the rear fuse panel is located in the luggage compartment. On 1998-2004 models, the rear fuse panel is located under the rear seat.
- On all models, remove the two retaining screws from the rear edge of the lefthand sound insulator.
- Push in on the snap tabs to release the insulator.
- Discon...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Seville CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2002 Cadillac Seville AUTOMOBILES
General Motors Corp./Saturn Cars -> Traction Control System (TCS) Warning Lamp ->
Vehicle: 2002 Cadillac Seville STS 4.6 V8 GAS
This lamp should light for a approximately 6-8 seconds when the ignition is turned on as a bulb check. If the warni...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Seville MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2002 Cadillac Seville AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2002 Cadillac Seville STS 4.6 V8 GAS
Lower
- Disconnect negative battery cable.
- Raise and support vehicle.
- Remove lower front air deflector.
- Drain cooling system into a suitable container.
- Lower vehicle.
- Reposition hose clamp from engine.
- Remove radiator outlet hose from engine.
- Reposition hose clamp from radiator.
- Remove radiator outlet hose from radiator and vehicle.
- Reverse procedure...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Seville RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2002 Cadillac Seville AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2002 Cadillac Seville SLS 4.6 V8 GAS
- Rotate drive belt tensioner mechanism upward, away from drive ...
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Seville SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2002 Cadillac Seville AUTOMOBILES
Component location diagrams for most 2002 Cadillac Seville cars and light trucks sold in the U.S. from 1990+.
Right Side Under the IP Diagram for 2002 Cadillac Seville SLS 4.6 V8 GAS Components on diagram: |
Below Center of IP Diagram for 2002 Cadillac Seville STS 4.6 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Seville PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2002 Cadillac Seville AUTOMOBILES
OEM drawn wiring diagrams for most 2002 Cadillac Seville cars and light trucks sold in the U.S.
2002 Cadillac Seville SLS 4.6 V8 GAS Wiring Diagram Components on diagram: |
2002 Cadillac Seville SLS 4.6 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Seville WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2002 Cadillac Seville AUTOMOBILES
OEM TSB listings for most 2002 Cadillac Seville cars and light trucks sold in the U.S. from 1985+.
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2002 Cadillac Seville SLS 4.6 V8 GAS Auto Systems: |
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 2002 Cadillac Seville SLS 4.6 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Seville TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2002 Cadillac Seville AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2002 Cadillac Seville cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2002 Cadillac Seville cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2002 Cadillac Seville cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2002 Cadillac Seville cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2002 Cadillac Seville SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2002 Cadillac Seville vehicle. |
Access the Complete guide! |