Auto Parts Search
2000 Volvo S70 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Volvo REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2000 Volvo S70 AUTOMOBILES
Volvo -> Electric Cooling Fans -> Component Diagnosis & Testing -> Engine Cooling Fan And Relay -> Micro-Switch -> S90 & V90 -> Thermal Switch
Vehicle: 2000 Volvo S70 2.4 L5 GAS
S90 & V90
Engine Cooling Fan And Relay
- Turn ignition to On position.
- Connect suitable jumper wire between thermal switch electrical connector terminals. Do not disconnect electrical connector.
- With jumper wire properly installed, the engine cooling fan should activate.
- If fan does not operate, visually inspect relay, relay wiring and electrical connector for open and/or short circuits, relay for correct installation, incorrectly grounded and/or damaged electrical connector.
- After conducting repairs on wiring, relay or...
CLICK HERE TO GET FULL ACCESS TO 2000 Volvo S70 A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2000 Volvo S70 AUTOMOBILES
Anti-lock Brakes -> Description
Vehicle: 2000 Volvo S70 2.4 L5 GAS
The Anti-Lock Brake System (ABS) uses a control unit, hydraulic modulator, transient surge protector, front speed sensors and a speedometer sensor to control wheel lock-up. The control unit receives vehicle speed, wheel speed and wheel acceleration information from the sensors, then sends the information to the hydraulic modulator. The hydraulic modulator uses this information to ensure correct hydraulic pr...
CLICK HERE TO GET FULL ACCESS TO 2000 Volvo S70 BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2000 Volvo S70 AUTOMOBILES
Volvo -> Fuel Filter Replacement -> S70, V70, XC70 & 850
Vehicle: 2000 Volvo S70 2.3 L5 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Always disconnect the battery ground cable before replacing the fuel filter. Position a shop towel over fuel filter connections before disconnecting.
- Remove the throttle pulley cover and shield over the valve on fuel rail.
- Connect adapter tool (Volvo tool No. 999 5484 or equivalent), to fuel drainage unit (Volvo tool Nos. 981 2270, 2273 and 2282 or equivalents).
- Connect the adapter to va...
CLICK HERE TO GET FULL ACCESS TO 2000 Volvo S70 FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2000 Volvo S70 AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 2000 Volvo S70 2.4 L5 GAS
- Raise and support vehicle.
- Remove front member from body, exhaust pipe and three-way catalytic converter (TWC).
- Remove brake pipe from mountings in member.
- Remove front propeller shaft. If same propeller shaft is to be reinstalled, mark propeller shaft CV joint in relation to bevel gear flange.
- Remove screws from propeller shaft. Use a suitable counterhold tool.
- Remove rear section of exhaust system.
- Support front section of exhaust pipe so as not to put strain on exhaust manifold.
- Remove rear exhaust system assembly.
- Remove rear propeller shaft. If same propeller shaft is to be reu...
CLICK HERE TO GET FULL ACCESS TO 2000 Volvo S70 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2000 Volvo S70 AUTOMOBILES
Starter, Replace
Vehicle: 2000 Volvo S70 2.4 L5 GAS
- Remove hose and pipe for charge air cooler.
- Remove splash guard.
- Remove power cable and antenna from starter motor.
- ...
CLICK HERE TO GET FULL ACCESS TO 2000 Volvo S70 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2000 Volvo S70 AUTOMOBILES
Cabin Air Filter Service -> Volvo -> 1993-97 850 & 1997-2000 C70, S70 & V70
Vehicle: 2000 Volvo S70 2.3 L5 GAS
The cabin air filter should be replaced every 24 months or 20,000 miles. The filter should be replaced more often if air flow is less than normal.
- Note the position of the windshield wiper blades on the windshield.
- Remove the windshield wiper arm retaining nuts, then the wiper arms.
- Remove the upper cowl panel retaining screws.
- Disconnect hoses and clamp...
CLICK HERE TO GET FULL ACCESS TO 2000 Volvo S70 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2000 Volvo S70 AUTOMOBILES
Volvo -> Check Engine Lamp ->
Vehicle: 2000 Volvo S70 2.4 L5 GAS
This lamp should be illuminated when the ignition switch is placed in the On position. After the engine has been started, the lamp should go out. If it remains lit, a problem has b...
CLICK HERE TO GET FULL ACCESS TO 2000 Volvo S70 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2000 Volvo S70 AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2000 Volvo S70 2.3 L5 GAS
Inlet
- Drain coolant into a suitable container.
- Reposition clamp on heat exchanger feed pipe and remove hose.
- Reposition clamp on cylinder head nipple and remove hose.
- Remove hose from vehicle.
- Reverse procedur...
CLICK HERE TO GET FULL ACCESS TO 2000 Volvo S70 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2000 Volvo S70 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2000 Volvo S70 2.4 L5 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 2000 Volvo S70 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2000 Volvo S70 AUTOMOBILES
Component location diagrams for most 2000 Volvo S70 cars and light trucks sold in the U.S. from 1990+.
Accelerator Pedal Sensor, Clutch Pedal Sensor & Brake Pedal Sensor Diagram for 2000 Volvo S70 2.3 L5 GAS Components on diagram: |
Control Modules & Sensors Diagram for 2000 Volvo S70 2.3 L5 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2000 Volvo S70 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2000 Volvo S70 AUTOMOBILES
OEM drawn wiring diagrams for most 2000 Volvo S70 cars and light trucks sold in the U.S.
2000 Volvo S70 2.4 L5 GAS Wiring Diagram Components on diagram: |
2000 Volvo S70 2.4 L5 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2000 Volvo S70 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2000 Volvo S70 AUTOMOBILES
OEM TSB listings for most 2000 Volvo S70 cars and light trucks sold in the U.S. from 1985+.
Document: TRANSMISSION CONTROL MODULE (TCM), SOFTWARE (SW) - REVISED Vehicle: 2000 Volvo S70 2.3 L5 GAS Auto Systems: |
Document: STUCK CDS IN AUDIO UNIT Vehicle: 2000 Volvo S70 2.3 L5 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2000 Volvo S70 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2000 Volvo S70 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2000 Volvo S70 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2000 Volvo S70 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2000 Volvo S70 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2000 Volvo S70 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2000 Volvo S70 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2000 Volvo S70 vehicle. |
Access the Complete guide! |