Auto Parts Search
2000 Hyundai Tiburon CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Hyundai REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2000 Hyundai Tiburon AUTOMOBILES
A/C Data -> Imported Passenger Cars, Light Trucks & Vans -> Hyundai -> 1992-2002 -> 2003-04
Vehicle: 2000 Hyundai Tiburon 2.0 L4 GAS
1992-2002
... [[table data]] [[table data]]CLICK HERE TO GET FULL ACCESS TO 2000 Hyundai Tiburon A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2000 Hyundai Tiburon AUTOMOBILES
Disc Brakes -> Caliper Service -> Accent -> Assemble -> Disassemble -> Elantra & Tiburon -> Elantra, Sonata & Tiburon -> Front -> Installation -> Rear -> Removal -> Santa Fe -> Sonata -> XG 300 & XG 350
Vehicle: 2000 Hyundai Tiburon 2.0 L4 GAS
Front
Accent
Removal
- Remove wheel/tire assembly.
- Remove brake hose from caliper and cap brake line(s).
- Remove caliper assembly as outlined under, "Brake Pad Service."
Disassemble
- Remove sleeve, sleeve boot and pin boots, Fig. .
- Protect fingers with shop towel, then blow piston from caliper bore with compressed air.
- Remove piston boot, then pry piston seal from caliper bore using a suitable screwdriver.
Assemble
- Clean all components with suitable cleaner.
- Inspect caliper bore, piston and carrier for damage or excessive wear.
- Apply suitable rubber grease to new piston seal, then install piston s...
CLICK HERE TO GET FULL ACCESS TO 2000 Hyundai Tiburon BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2000 Hyundai Tiburon AUTOMOBILES
Hyundai -> Fuel Filter Replacement -> All Models -> Fuel System Relief -> Removal & Installation
Vehicle: 2000 Hyundai Tiburon 2.0 L4 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur.
Fuel System Relief
- Disc...
CLICK HERE TO GET FULL ACCESS TO 2000 Hyundai Tiburon FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2000 Hyundai Tiburon AUTOMOBILES
CV AXLE SHAFT, Replace -> Front
Vehicle: 2000 Hyundai Tiburon 2.0 L4 GAS
Front
- Raise and support vehicle and support it with safety stands in proper locations.
- Remove wheel nuts and front wheels.
- Remove driveshaft nuts from front hubs.
- Remove lower arm ball joint front knuckle. Tie cord of special tool to nearby part.
- Detach tie rod end ball joint connection.
- Remove stabilizer bar self locking nut and stabilizer bar connection.
- Remove drain plug and drain transaxle fluid in suitable container.
- Insert suitable tool between transaxle case and driveshaft assembly, then separate driveshaft from transaxle assembly. Always use care not to damage transaxle a...
CLICK HERE TO GET FULL ACCESS TO 2000 Hyundai Tiburon DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2000 Hyundai Tiburon AUTOMOBILES
Alternator, Replace
Vehicle: 2000 Hyundai Tiburon 2.0 L4 GAS
- Disconnect battery ground cable.
- Loosen alternator tensioning and mounting bolts, then remove drive belt.
- Raise and support vehicle.
- Remove right side splash shield.
- Disconnect electri...
CLICK HERE TO GET FULL ACCESS TO 2000 Hyundai Tiburon STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2000 Hyundai Tiburon AUTOMOBILES
Hyundai -> Electronic Stability Control (ESC) Warning Lamp ->
Vehicle: 2000 Hyundai Tiburon 2.0 L4 GAS
The ESC warning lamp is used to warn of a system fault. It will be lit when the ignition switch is placed in the on position, but should go out when the self-diagnostic system determines that the system is functioning properly. The lamp will flash when the ...
CLICK HERE TO GET FULL ACCESS TO 2000 Hyundai Tiburon MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2000 Hyundai Tiburon AUTOMOBILES
Heater Hose, Replace -> Bypass -> Inlet -> Outlet
Vehicle: 2000 Hyundai Tiburon 2.0 L4 GAS
Inlet
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at heater core.
- Remove hose from heater core.
- Reposition hose clamp at thermostat housing.
- Remove hose from thermostat housing.
- Remove hose from vehicle.
- Reverse procedure to install.
Outlet
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at heater c...
CLICK HERE TO GET FULL ACCESS TO 2000 Hyundai Tiburon RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2000 Hyundai Tiburon AUTOMOBILES
Serpentine Drive Belt, Replace -> Air Conditioning -> Alternator -> Power Steering
Vehicle: 2000 Hyundai Tiburon 2.0 L4 GAS
Alternator
- Disconnect battery ground cable from battery.
- Loosen alternator upper locknut.
- Loosen lower mounting nut.
- Push alternator inward toward engine.
- Remove alternator drive belt.
- Clean and inspect belt surfaces of all pulleys.
- Reverse procedure to install, noting the following:
- Torque alternator mounting nut and bolt to 18 ft. lbs.
- Torque alternator adjustment lockbolt to 11 ft. lbs.
- Torque alternator brace mounting bolt to 17 ft. lbs.
Air Conditioning
- D...
CLICK HERE TO GET FULL ACCESS TO 2000 Hyundai Tiburon SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2000 Hyundai Tiburon AUTOMOBILES
Component location diagrams for most 2000 Hyundai Tiburon cars and light trucks sold in the U.S. from 1990+.
I/P Wiring Harness Connector Location Diagram for 2000 Hyundai Tiburon 2.0 L4 GAS Components on diagram: |
Luggage Compartment & Rear Wiring Harness Connector Location Diagram for 2000 Hyundai Tiburon 2.0 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2000 Hyundai Tiburon PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2000 Hyundai Tiburon AUTOMOBILES
OEM drawn wiring diagrams for most 2000 Hyundai Tiburon cars and light trucks sold in the U.S.
2000 Hyundai Tiburon 2.0 L4 GAS Wiring Diagram Components on diagram: |
2000 Hyundai Tiburon 2.0 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2000 Hyundai Tiburon WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2000 Hyundai Tiburon AUTOMOBILES
OEM TSB listings for most 2000 Hyundai Tiburon cars and light trucks sold in the U.S. from 1985+.
Document: ALARM SELF ACTIVATES - HOOD SWITCH PAD REPLACEMENT Vehicle: 2000 Hyundai Tiburon 2.0 L4 GAS |
Document: NEW REPLACEMENT WIRING HARNESSES FOR TIBURON (GK) AND SANTA FE (CM) WIRING REPAIR Vehicle: 2000 Hyundai Tiburon 2.0 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2000 Hyundai Tiburon TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2000 Hyundai Tiburon AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2000 Hyundai Tiburon cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2000 Hyundai Tiburon cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2000 Hyundai Tiburon cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2000 Hyundai Tiburon cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2000 Hyundai Tiburon SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2000 Hyundai Tiburon vehicle. |
Access the Complete guide! |