Auto Parts Search
1999 Pontiac Firebird CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Pontiac REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 1999 Pontiac Firebird AUTOMOBILES
Electrical Symbol & Wire Color Code Identification -> Wire Color Code Identification -> Domestic Vehicles
Vehicle: 1999 Pontiac Firebird Formula 5.7 V8 GAS
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Firebird A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1999 Pontiac Firebird AUTOMOBILES
Disc Brakes -> PBR Single Piston Rear Disc Brake -> Brake Pad Service -> Installation -> Removal
Vehicle: 1999 Pontiac Firebird Formula 5.7 V8 GAS
Removal
- Remove 2/3 of total brake fluid capacity from master cylinder reservoir.
- Raise and support vehicle, then remove tire and wheel assembly.
- Install two wheel lug nuts to retain rotor in position.
- Position one end of a suitable C-clamp against inlet fitting bolt and other end against outboard shoe and lining.
- Tighten clamp, Fig. , until piston fully bottoms in caliper bore.
- Remove upper guide pin bolt and discard.
- Loosen lower guide pin bolt, then pivot caliper downward on lower guide pin bolt to expose shoe and lining assemblies.
- Remove shoes and linings from mounting bracket.
Ins...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Firebird BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1999 Pontiac Firebird AUTOMOBILES
General Motors Corp./Saturn Passenger Cars -> Fuel Pressure Relief -> Except Aveo, LaCrosse, LeMans (1988-93), Malibu & Malibu Maxx (2004-05), Metro, Nova, Prizm, Spectrum & Storm -> Engine Fuel Pressure Service Port -> Engines Less Fuel Pressure Service Port
Vehicle: 1999 Pontiac Firebird Trans AM 5.7 V8 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the vehicle relearns its adaptive strateg...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Firebird FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1999 Pontiac Firebird AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assembly -> Disassembly
Vehicle: 1999 Pontiac Firebird Formula 5.7 V8 GAS
Disassembly
- Support propeller shaft in a horizontal position that is aligned with base plate of a press.
- Place universal joint so that lower ear of shaft yoke is supported on a 29mm (1.125 inch) socket.
- In order to remove lower bearing cap from yoke ear proceed as follows:
- Place U-Joint Bearing Separator J 9522 - 3 or equivalent on open horizontal bearing cap.
- Press lower bearing cap out of yoke ear. This process shears nylon injected ring on lower bearing cap.
- If bearing cap is not completely removed, use following steps in order to completely remove bearing cap:
- Lift U-Jo...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Firebird DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1999 Pontiac Firebird AUTOMOBILES
Starter, Replace
Vehicle: 1999 Pontiac Firebird 3.8 V6 GAS
This vehicle was designed for starter mounting without shims. If single or double shims have been added to correct a noise or engagement problem, they should be reinstalled in their original positions to ensure proper pinion to flywheel assembl...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Firebird STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1999 Pontiac Firebird AUTOMOBILES
General Motors Corp./Saturn Cars -> Change Oil, Change Oil Now Or Change Oil Soon Lamp & Messages -> 1999-2002 Firebird
Vehicle: 1999 Pontiac Firebird 3.8 V6 GAS
- Turn ignition to Run, engine Off.
- Press TRIP/OIL RESET button on instrument panel for 12 seconds. The OIL CHAN...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Firebird MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1999 Pontiac Firebird AUTOMOBILES
Radiator, Replace
Vehicle: 1999 Pontiac Firebird Trans AM 5.7 V8 GAS
- Recover refrigerant.
- Drain cooling system into suitable container, then remove radiator hoses.
- Remove upper evaporator tube bracket bolt, Fig. .
- Remove evaporator tube from condenser.
- Remove upper and lower oil cooler lines from radiator, if equipped.
- Remove condenser tube from condenser, Fi...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Firebird RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1999 Pontiac Firebird AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 1999 Pontiac Firebird 3.8 V6 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Firebird SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1999 Pontiac Firebird AUTOMOBILES
Component location diagrams for most 1999 Pontiac Firebird cars and light trucks sold in the U.S. from 1990+.
Under Center Of I/P Diagram for 1999 Pontiac Firebird 3.8 V6 GAS Components on diagram: |
Rear Center Of Roof Diagram for 1999 Pontiac Firebird Trans AM 5.7 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Firebird PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1999 Pontiac Firebird AUTOMOBILES
OEM drawn wiring diagrams for most 1999 Pontiac Firebird cars and light trucks sold in the U.S.
1999 Pontiac Firebird Formula 5.7 V8 GAS Wiring Diagram Components on diagram: |
1999 Pontiac Firebird 3.8 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Firebird WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1999 Pontiac Firebird AUTOMOBILES
OEM TSB listings for most 1999 Pontiac Firebird cars and light trucks sold in the U.S. from 1985+.
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 1999 Pontiac Firebird 3.8 V6 GAS Auto Systems: |
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 1999 Pontiac Firebird 3.8 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Firebird TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1999 Pontiac Firebird AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1999 Pontiac Firebird cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1999 Pontiac Firebird cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1999 Pontiac Firebird cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1999 Pontiac Firebird cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Firebird SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1999 Pontiac Firebird vehicle. |
Access the Complete guide! |