Auto Parts Search
1998 Saab 900 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Saab REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 1998 Saab 900 AUTOMOBILES
Saab -> Component Replacement & Adjustment -> Air Recirculation Flap Servo Motor, Replace -> 9000
Vehicle: 1998 Saab 900 S 2.3 L4 GAS
9000
- Remove rubber strip and cover over bulkhead cowl area.
- Disconnect windshield washer hose.
- Free righthand shield plates.
- Open brace over A/C lines.
- Remove two evaporator casing screws.
- Pull evaporator casing forward slightly to access both se...
CLICK HERE TO GET FULL ACCESS TO 1998 Saab 900 A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1998 Saab 900 AUTOMOBILES
Disc Brakes -> Tightening Specifications
Vehicle: 1998 Saab 900 S 2.3 L4 GAS
CLICK HERE TO GET FULL ACCESS TO 1998 Saab 900 BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1998 Saab 900 AUTOMOBILES
Saab -> Fuel Filter Replacement -> 1994-98 900 -> Fuel System Pressure Relief -> Removal & Installation
Vehicle: 1998 Saab 900 SE Turbo 2.0 L4 GAS
Fuel System Pressure Relief
- Remove fuel pump fuse No. 32 from the instrument panel fuse box.
- Start the engine and run until it stalls.
- Turn the ignition Off.
- Disconnect the battery ground cable.
- Install the fuel pump fuse.
Removal & Installation
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be r...
CLICK HERE TO GET FULL ACCESS TO 1998 Saab 900 FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1998 Saab 900 AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 1998 Saab 900 S 2.3 L4 GAS
- Remove dust cap and loosen hub center nut, Fig. . Do not completely remove nut.
- Raise and support vehicle, then remove wheel.
- Remove hub center nut, then ball joint nut.
- Remove ball joint using a suitable ball joint tool.
- Remove anti-roll bar nut and collect washer and rubber bushing.
- Press spring link down.
- Tap driveshaft out of hub using rubber mallet, then move MacPherson strut aside and pull out d...
CLICK HERE TO GET FULL ACCESS TO 1998 Saab 900 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1998 Saab 900 AUTOMOBILES
Alternator, Replace
Vehicle: 1998 Saab 900 SE Turbo 2.0 L4 GAS
- Disconnect battery ground cable at battery.
- Remove air-filter canister and induction hose between canister and throttle body.
- Remove belt tensioner.
- Raise and support vehicle.
- Remove right front wheel.
- Remove cover over belt circuit.
- Undo alternator'...
CLICK HERE TO GET FULL ACCESS TO 1998 Saab 900 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 1998 Saab 900 AUTOMOBILES
Cabin Air Filter Service -> Saab -> 1994-98 900 & 1999-2002 9-3
Vehicle: 1998 Saab 900 S 2.3 L4 GAS
The cabin air filter should be replaced every 30,000 miles. The filter should be replaced more often if air flow is less than normal.
- Disconnect the battery ground cable.
- Note the position of the windshield wiper blades on the windshield.
- Remove the windshield wiper arm retaining nuts, then the wiper arms.
- Remove the cowl panel retaining screws.
- Disconnect hoses and clamps from the upper cowl panel, then remove the panel.
- Remove the windshield wiper motor and linkage attaching s...
CLICK HERE TO GET FULL ACCESS TO 1998 Saab 900 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1998 Saab 900 AUTOMOBILES
Saab -> Low Fuel Level Warning Lamp ->
Vehicle: 1998 Saab 900 SE Turbo 2.0 L4 GAS
When fuel tank fuel level falls below 2.64 gallons, the low fuel level warning lamp illumin...
CLICK HERE TO GET FULL ACCESS TO 1998 Saab 900 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1998 Saab 900 AUTOMOBILES
Radiator, Replace
Vehicle: 1998 Saab 900 SE Turbo 2.0 L4 GAS
- Remove charge air cooler.
- Remove grille.
- Release engine oil cooler (as equipped) and hang it up in such a way that hoses are not damaged.
- Remove condenser from radiator.
- Disconnect and remove battery.
- Remove battery shelf.
- Open drain plug and drain coolant.
- Remove lid on expansion tank to speed up draining.
- Remove bypass hose together with intake hose.
- Undo upper radiator hoses from radiator.
- Separate radiator fan's electrical connections.
- Release servo pump's oil pipe and clips for radiator's breather hos...
CLICK HERE TO GET FULL ACCESS TO 1998 Saab 900 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1998 Saab 900 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 1998 Saab 900 SE Turbo 2.0 L4 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 1998 Saab 900 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1998 Saab 900 AUTOMOBILES
Component location diagrams for most 1998 Saab 900 cars and light trucks sold in the U.S. from 1990+.
Engine Compartment Relay Locations Diagram for 1998 Saab 900 S 2.3 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1998 Saab 900 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1998 Saab 900 AUTOMOBILES
OEM drawn wiring diagrams for most 1998 Saab 900 cars and light trucks sold in the U.S.
1998 Saab 900 SE Turbo 2.0 L4 GAS Wiring Diagram Components on diagram: |
1998 Saab 900 S Turbo 2.0 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1998 Saab 900 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1998 Saab 900 AUTOMOBILES
OEM TSB listings for most 1998 Saab 900 cars and light trucks sold in the U.S. from 1985+.
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 1998 Saab 900 S 2.3 L4 GAS Auto Systems: |
Document: WARRANTY ADMINISTRATION - POLICIES FOR USED VEHICLES PURCHASED THROUGH GM-SPONSORED AUCTIONS Vehicle: 1998 Saab 900 S 2.3 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 1998 Saab 900 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1998 Saab 900 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1998 Saab 900 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1998 Saab 900 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1998 Saab 900 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1998 Saab 900 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1998 Saab 900 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1998 Saab 900 vehicle. |
Access the Complete guide! |