Auto Parts Search
1997 Isuzu Rodeo CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Isuzu REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 1997 Isuzu Rodeo AUTOMOBILES
Isuzu -> Component Replacement & Adjustment -> Blower Mode Door, Replace
Vehicle: 1997 Isuzu Rodeo 2.6 L4 GAS
For Hombre refer to S/T Series in .
For Oasis refer to Honda Odyssey .
- On models with A/C, recover refrigerant as outlined under .
- On all models, remove dash panel as outlined under "Dash Panel, Replace," Figs. and .
- On Rodeo models, remove clips, mounting screw and center and lower vent duct.
- On all models, remove resistor connector.
- On models less A/C, remove duct.
- On models with A/C, remove evaporator as outlined under "Evaporator, Re... "
CLICK HERE TO GET FULL ACCESS TO 1997 Isuzu Rodeo A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1997 Isuzu Rodeo AUTOMOBILES
Anti-lock Brakes -> Diagnosis & Testing -> 1997 Four Wheel Anti-Lock Brakes -> 1998-2001 Four Wheel Anti-Lock Brakes -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Clearing DTCs -> Diagnosis By Symptom -> Diagnostic Circuit Inspection -> Diagnostic Tests -> Diagnostic Trouble Code Interpretation -> Less Tech 1 Scan Tool -> Less Tech 2 Scan Tool -> Pinout Tests -> Rear Wheel ABS -> Rodeo -> Self-Diagnosis -> Trooper -> Wiring Circuit -> Wiring Circuits -> Wiring Diagrams -> With Tech 1 Scan Tool -> With Tech 2 Scan Tool
Vehicle: 1997 Isuzu Rodeo 3.2 V6 GAS
Some diagnostic procedures require that the ignition switch remain On for extended periods of time while tests are performed. Low battery voltage may result, causing erroneous voltage readings. If vehicle system voltage becomes low, it is advisable to connect a battery charger and apply a slow charge while testing.
Rear Wheel ABS
Self-Diagnosis
The RWAL system performs a self-check every time the ignition key is turned from Off to On position. The system inspection consists of the following:
- Inspects the rear anti-lock light by illuminating for approximately two seconds.
- Inspects...
CLICK HERE TO GET FULL ACCESS TO 1997 Isuzu Rodeo BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1997 Isuzu Rodeo AUTOMOBILES
Isuzu -> Fuel Filter Scheduled Maintenance -> 1988-04 Amigo, Axiom, Pickup, Rodeo, Trooper & VehiCROSS -> Normal Service -> Severe Service
Vehicle: 1997 Isuzu Rodeo 3.2 V6 GAS
Normal Service
Service interval n...
CLICK HERE TO GET FULL ACCESS TO 1997 Isuzu Rodeo FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1997 Isuzu Rodeo AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assembly -> Disassemble -> Snap Ring Type
Vehicle: 1997 Isuzu Rodeo 3.2 V6 GAS
Disassemble
Snap Ring Type
This procedure describes a driveline equipped with cardan joint in tube yoke. Driveline equipped wit companion/slip yoke repeat steps to remove remaining cardan joint.
- Place driveshaft on suitable workbench. Do not damage driveshaft when servicing on workbench. Ensure driveline and components are reference marked to prevent driveline imbalance.
- Tap outside of bearing cap with a drift to loosen snap ring.
- Remove snap rings from both sides of yoke using suitable tool.
- Position yoke with grease fitting pointing up, if equipped.
- Position socket with a...
CLICK HERE TO GET FULL ACCESS TO 1997 Isuzu Rodeo DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1997 Isuzu Rodeo AUTOMOBILES
Starter, Replace
Vehicle: 1997 Isuzu Rodeo 3.2 V6 GAS
- Disconnect battery ground cable.
- Disconnect wiring from solenoid.
- Remove starter motor mounting bolts and nuts, then starter assem...
CLICK HERE TO GET FULL ACCESS TO 1997 Isuzu Rodeo STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1997 Isuzu Rodeo AUTOMOBILES
Isuzu -> Check Trans. Indicator Lamp -> Amigo, Axiom, Rodeo, Rodeo Sport, Trooper & VehiCROSS
Vehicle: 1997 Isuzu Rodeo 2.6 L4 GAS
On models equipped with automatic transmission,the Check Trans. lamp should illuminate for a few seconds after the ignition switch is placed in the on position. If the lamp is flashing, the computer controlling the transmission has detected a fault. The computer will place the transmission in the back up mode. In...
CLICK HERE TO GET FULL ACCESS TO 1997 Isuzu Rodeo MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1997 Isuzu Rodeo AUTOMOBILES
Radiator, Replace
Vehicle: 1997 Isuzu Rodeo 2.6 L4 GAS
- Drain engine coolant into suitable container, then remove upper radiator hose, Fig. .
- Remove mounting bolts from deflector, then air intake duct.
- Remove lower radiator hose, then disconnect coolant...
CLICK HERE TO GET FULL ACCESS TO 1997 Isuzu Rodeo RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1997 Isuzu Rodeo AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 1997 Isuzu Rodeo 3.2 V6 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 1997 Isuzu Rodeo SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1997 Isuzu Rodeo AUTOMOBILES
Component location diagrams for most 1997 Isuzu Rodeo cars and light trucks sold in the U.S. from 1990+.
Description Reference Table Diagram for 1997 Isuzu Rodeo 2.6 L4 GAS Components on diagram: |
Engine Compartment Component Locations Diagram for 1997 Isuzu Rodeo 2.6 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1997 Isuzu Rodeo PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1997 Isuzu Rodeo AUTOMOBILES
OEM drawn wiring diagrams for most 1997 Isuzu Rodeo cars and light trucks sold in the U.S.
1997 Isuzu Rodeo 3.2 V6 GAS Wiring Diagram Components on diagram: |
1997 Isuzu Rodeo 2.6 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1997 Isuzu Rodeo WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1997 Isuzu Rodeo AUTOMOBILES
OEM TSB listings for most 1997 Isuzu Rodeo cars and light trucks sold in the U.S. from 1985+.
Document: WARRANTY PROCEDURES Vehicle: 1997 Isuzu Rodeo 2.6 L4 GAS Auto Systems: |
Document: MANUAL TRANSMISSION OPERATING CHARACTERISTICS - REVISED Vehicle: 1997 Isuzu Rodeo 2.6 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 1997 Isuzu Rodeo TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1997 Isuzu Rodeo AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1997 Isuzu Rodeo cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1997 Isuzu Rodeo cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1997 Isuzu Rodeo cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1997 Isuzu Rodeo cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1997 Isuzu Rodeo SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1997 Isuzu Rodeo vehicle. |
Access the Complete guide! |