Auto Parts Search
1994 Audi 90 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Audi REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 1994 Audi 90 AUTOMOBILES
Drive Belt Data -> Imported Cars & Light Trucks & Vans -> 1991-95
Vehicle: 1994 Audi 90 CS 2.8 V6 GAS
CLICK HERE TO GET FULL ACCESS TO 1994 Audi 90 A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1994 Audi 90 AUTOMOBILES
Disc Brakes -> Dual Piston Front Disc Brakes -> Brake Rotor Replacement
Vehicle: 1994 Audi 90 CS 2.8 V6 GAS
Refer to "Front Suspension & Steering" or "Rear Axle &... "
CLICK HERE TO GET FULL ACCESS TO 1994 Audi 90 BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1994 Audi 90 AUTOMOBILES
Audi -> Component Locations -> 1991-05 2.8L V6
Vehicle: 1994 Audi 90 CS 2.8 V6 GAS
Refer to Fig...
CLICK HERE TO GET FULL ACCESS TO 1994 Audi 90 FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1994 Audi 90 AUTOMOBILES
CV AXLE SHAFT, Replace -> Less Attached Wheel Bearing Housing -> W/Attached Wheel Bearing Housing
Vehicle: 1994 Audi 90 CS 2.8 V6 GAS
W/Attached Wheel Bearing Housing
- Loosen wheel bolts.
- Remove wheel hub to axle shaft bolt.
- Raise and support vehicle, then remove washer and wheel.
- Remove axle shaft flange, nut from link rod, and control arm to stabilizer bar to subframe mounting bolts.
- Push control arm downward, then press axle shaft out of hub using a suitable puller.
- Reverse procedure to install, noting the following:
- Ensure splines on stub axle and wheel hub are free of oil, grease and old locking compound.
- Apply a .2 inch (5mm) band of D6 locking compound around end of outer CV joint splines, then install ax...
CLICK HERE TO GET FULL ACCESS TO 1994 Audi 90 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1994 Audi 90 AUTOMOBILES
Alternator, Replace
Vehicle: 1994 Audi 90 CS 2.8 V6 GAS
- Disconnect battery ground cable.
- Remove serpentine drive belt Fig. , then disconnect electrical connections from alternator.
- Remove alternator mounting bolts and brackets, then ...
CLICK HERE TO GET FULL ACCESS TO 1994 Audi 90 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1994 Audi 90 AUTOMOBILES
Audi -> Brake Pad Wear Indicator Lamp ->
Vehicle: 1994 Audi 90 CS 2.8 V6 GAS
The brake pad wear warning lamp will be illuminated when disc brake pads wear d...
CLICK HERE TO GET FULL ACCESS TO 1994 Audi 90 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1994 Audi 90 AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 1994 Audi 90 S 2.8 V6 GAS
Lower
- Drain coolant into a suitable container.
- Reposition hose clamp at radiator and remove hose.
- Reposition hose clamp at thermostat housing and remove hose.
- Remove hose from vehicle.
- Reverse procedure ...
CLICK HERE TO GET FULL ACCESS TO 1994 Audi 90 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1994 Audi 90 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 1994 Audi 90 CS 2.8 V6 GAS
Mark direction of belt travel before removing, using a crayon or marker. Reinstalling a used belt in opposite direction could damage belt.
- Remove driv...
CLICK HERE TO GET FULL ACCESS TO 1994 Audi 90 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1994 Audi 90 AUTOMOBILES
Component location diagrams for most 1994 Audi 90 cars and light trucks sold in the U.S. from 1990+.
Auxiliary Relay Panel Diagram for 1994 Audi 90 CS 2.8 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1994 Audi 90 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1994 Audi 90 AUTOMOBILES
OEM drawn wiring diagrams for most 1994 Audi 90 cars and light trucks sold in the U.S.
1994 Audi 90 S 2.8 V6 GAS Wiring Diagram Components on diagram: |
1994 Audi 90 S 2.8 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1994 Audi 90 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1994 Audi 90 AUTOMOBILES
OEM TSB listings for most 1994 Audi 90 cars and light trucks sold in the U.S. from 1985+.
Document: AIRBAG / PYROTECHNIC SAFETY BELT DEPLOYMENT INQUIRIES - REVISED Vehicle: 1994 Audi 90 CS 2.8 V6 GAS Auto Systems: |
Document: LATCH SYSTEM, INSTALLING/RETROFITTING - REVISED Vehicle: 1994 Audi 90 CS 2.8 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 1994 Audi 90 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1994 Audi 90 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1994 Audi 90 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1994 Audi 90 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1994 Audi 90 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1994 Audi 90 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1994 Audi 90 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1994 Audi 90 vehicle. |
Access the Complete guide! |