Auto Parts Search
1993 GEO Storm CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT GEO REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 1993 GEO Storm AUTOMOBILES
Air Bag System Precautions -> General Motors Corp. -> Arming -> Light Trucks & Vans -> Passenger Cars
Vehicle: 1993 GEO Storm GSI 1.8 L4 GAS
Passenger Cars
Reverse disarming procedures to arm the Supplemental Restraint System, noting the following:
- Ensure all disconnected SRS electrical connectors are securely connected and routed.
- Install all removed fuses in proper locations.
- From a safe position at sides of or below air bag module, Turn ignition switch to ON position and observe Air Bag or SRS warning lamp.
- On all models except Prizm and 1990 Corvette, warning lamp should flash seven to nine times, then go off.
- On Prizm models, warning lamp should light for six seconds,...
CLICK HERE TO GET FULL ACCESS TO 1993 GEO Storm A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1993 GEO Storm AUTOMOBILES
Power Brake Units -> General Service
Vehicle: 1993 GEO Storm 1.6 L4 GAS
Two basic types of power assist mechanisms are used: vacuum assist diaphragm assemblies, which use engine vacuum or, in some cases vacuum pressure developed by an external vacuum pump. The second type is a hydraulic pressure assist mechanism, which use pressure developed by an external pump (usually the power steering pump). Both systems act to increase the force exerted on the master cylinder piston by the operator. This in turn increases the hydraulic pressure delivered to the wheel cylinders, while decreasing driver effort necessary to obtain acceptable stopping performance.
V...
CLICK HERE TO GET FULL ACCESS TO 1993 GEO Storm BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1993 GEO Storm AUTOMOBILES
General Motors Corp./Saturn Passenger Cars -> Fuel Pressure Relief -> Spectrum & Storm
Vehicle: 1993 GEO Storm 2+2 1.6 L4 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal ...
CLICK HERE TO GET FULL ACCESS TO 1993 GEO Storm FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1993 GEO Storm AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 1993 GEO Storm GSI 1.8 L4 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- Drain transaxle fluid.
- Remove wheel assembly.
- Unstake hub nut, then remove nut.
- Remove tie rod end from steering knuckle.
- Disconnect lower control arm from steering knuckle.
- Remove drive axle from hub assembly, using a plastic hammer.
- Remove drive axle assembly from transaxle, using slide hammer (Tool No....
CLICK HERE TO GET FULL ACCESS TO 1993 GEO Storm DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1993 GEO Storm AUTOMOBILES
Alternator, Replace
Vehicle: 1993 GEO Storm GSI 1.8 L4 GAS
- Disconnect battery ground cable at battery.
- Disconnect heated oxygen sensor (HO2S).
- Remove heat shield from exhaust manifold.
- Release tension on drive belt by rotating tensioner.
- Remove drive belt.
- Remove two nuts and wiring harness retainer from power steering pump.
- Remove three bolts, electrical connector and power steering pump.
- Remove electrical connector from alternator.
- Remove nut from B+ terminal and remove wire.
- Raise and sup...
CLICK HERE TO GET FULL ACCESS TO 1993 GEO Storm STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1993 GEO Storm AUTOMOBILES
General Motors Corp./Saturn Cars -> Low Washer Fluid Indicator ->
Vehicle: 1993 GEO Storm 2+2 1.6 L4 GAS
The windshield washer solvent tank has a switch that closes when the wash...
CLICK HERE TO GET FULL ACCESS TO 1993 GEO Storm MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1993 GEO Storm AUTOMOBILES
Radiator, Replace
Vehicle: 1993 GEO Storm GSI 1.8 L4 GAS
- Drain coolant, into suitable container.
- Disconnect upper radiator hose from radiator.
- Remove two upper radiator fan shroud mounting bolts.
- Raise and support vehicle.
- Remove lower radiator fan shroud mounting bolts.
- Disconnect lower radiator hose from radiator.
- On models equipped with automatic transaxle,disconnect a...
CLICK HERE TO GET FULL ACCESS TO 1993 GEO Storm RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1993 GEO Storm AUTOMOBILES
Serpentine Drive Belt, Replace -> Installation -> Removal
Vehicle: 1993 GEO Storm 1.6 L4 GAS
Removal
- Rotate serpentine belt tensioner pulley clockwise to release tension from belt using a 3/8 drive socket wrench.
- Remove serpentine belt from pulleys.
Installation
- ...
CLICK HERE TO GET FULL ACCESS TO 1993 GEO Storm SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1993 GEO Storm AUTOMOBILES
Component location diagrams for most 1993 GEO Storm cars and light trucks sold in the U.S. from 1990+.
Engine Compartment Components Diagram for 1993 GEO Storm 2+2 1.6 L4 GAS Components on diagram: |
Engine Compartment Electrical Components Diagram for 1993 GEO Storm GSI 1.8 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1993 GEO Storm PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1993 GEO Storm AUTOMOBILES
OEM drawn wiring diagrams for most 1993 GEO Storm cars and light trucks sold in the U.S.
1993 GEO Storm 2+2 1.6 L4 GAS Wiring Diagram Components on diagram: |
1993 GEO Storm 1.6 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1993 GEO Storm WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1993 GEO Storm AUTOMOBILES
OEM TSB listings for most 1993 GEO Storm cars and light trucks sold in the U.S. from 1985+.
Document: INFORMATION ON USE OF DIAGNOSTIC WORKSHEET - REVISED Vehicle: 1993 GEO Storm 2+2 1.6 L4 GAS Auto Systems: |
Document: DIAGNOSIS OF CRACKED OR BROKEN TRANSMISSION CASE - REVISED Vehicle: 1993 GEO Storm 2+2 1.6 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 1993 GEO Storm TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1993 GEO Storm AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1993 GEO Storm cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1993 GEO Storm cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1993 GEO Storm cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1993 GEO Storm cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1993 GEO Storm SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1993 GEO Storm vehicle. |
Access the Complete guide! |