Auto Parts Search
1991 Daihatsu Charade CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Daihatsu REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 1991 Daihatsu Charade AUTOMOBILES
Daihatsu -> Component Replacement & Adjustment -> DUAL PRESSURE SWITCH, REPLACE -> CHARADE -> ROCKY
Vehicle: 1991 Daihatsu Charade SE 1.0 L3 GAS
CHARADE
- Disconnect battery ground terminal, then discharge refrigerant from system.
- Remove evaporator. Refer to <.
- Disassemble evaporator assembly, then remove pressure switch.
- Reverse procedure to install.
CLICK HERE TO GET FULL ACCESS TO 1991 Daihatsu Charade A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1991 Daihatsu Charade AUTOMOBILES
DAIHATSU, DISC BRAKES -> BRAKE PEDAL TRAVEL ADJUSTMENT
Vehicle: 1991 Daihatsu Charade SX 1.3 L4 GAS
- With engine off, pump brake pedal at least five times.
- Brake pedal free travel from a point where pedal is free to slight resistance should be .02-.08 inch on Charade or .04-.12 on ...
CLICK HERE TO GET FULL ACCESS TO 1991 Daihatsu Charade BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1991 Daihatsu Charade AUTOMOBILES
Diahatsu -> Fuel Filter Replacement -> All Models -> Fuel Pressure Relief -> Removal & Installation
Vehicle: 1991 Daihatsu Charade SE 1.3 L4 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
Fuel Pressure Relief
- Disconnect the battery ground cable prior to ...
CLICK HERE TO GET FULL ACCESS TO 1991 Daihatsu Charade FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1991 Daihatsu Charade AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 1991 Daihatsu Charade SX 1.3 L4 GAS
- Raise and support vehicle.
- Remove front wheels.
- Drain transmission fluid into a suitable container.
- Pull out driveshaft cotter pin, then remove wheel adjusting lock cap.
- Remove driveshaft nut , using SST tool or equivalent.
- Remove cotter pin and castle nut from tie rod end.
- Separate tie rod end from steering knuckle.
- Remove engine undercover at right and left side of vehicle.
- Remove stabilizer bar.
- Remove lower control arm from bracket, by removing lower control arm attaching nut.
- Remove extension rod bolts, then separate extension rod subassembly and shift selector subassembly fro...
CLICK HERE TO GET FULL ACCESS TO 1991 Daihatsu Charade DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1991 Daihatsu Charade AUTOMOBILES
Starter, Replace
Vehicle: 1991 Daihatsu Charade SX 1.3 L4 GAS
- Disconnect battery ground cable at battery.
- Disconnect all electrical wires from starter.
- Remove two starter mountin...
CLICK HERE TO GET FULL ACCESS TO 1991 Daihatsu Charade STARTER & ALTERNATOR REPLACEMENT PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1991 Daihatsu Charade AUTOMOBILES
Radiator, Replace
Vehicle: 1991 Daihatsu Charade SE 1.3 L4 GAS
- Disconnect battery ground cable from negitive terminal of battery.
- Open radiator cap and radiator drain plug, allow coolant to drain into a clean suitable container. Never open radiator cap or drain plug when engine is still hot.
- On automatic equipped models, disconnect oil cooler lines and plug from radiator.
- On ...
CLICK HERE TO GET FULL ACCESS TO 1991 Daihatsu Charade RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1991 Daihatsu Charade AUTOMOBILES
Serpentine Drive Belt, Replace -> Air Conditioning -> Alternator
Vehicle: 1991 Daihatsu Charade SE 1.0 L3 GAS
Air Conditioning
- Disconnect battery ground cable.
- Loosen idler pulley mount nut.
- Loosen adjusting bolt.
- Remove drive belt.
- Inspect belt and pulleys for contamination and d...
CLICK HERE TO GET FULL ACCESS TO 1991 Daihatsu Charade SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1991 Daihatsu Charade AUTOMOBILES
Component location diagrams for most 1991 Daihatsu Charade cars and light trucks sold in the U.S. from 1990+.
Stop Lamp Switch Diagram for 1991 Daihatsu Charade SX 1.3 L4 GAS Components on diagram: |
Electronic Components. Engine Compartment Diagram for 1991 Daihatsu Charade SE 1.0 L3 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1991 Daihatsu Charade PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1991 Daihatsu Charade AUTOMOBILES
OEM drawn wiring diagrams for most 1991 Daihatsu Charade cars and light trucks sold in the U.S.
1991 Daihatsu Charade SX 1.3 L4 GAS Wiring Diagram Components on diagram: |
1991 Daihatsu Charade SE 1.0 L3 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1991 Daihatsu Charade WIRING DIAGRAMS!
COMPONENT/PARTS SPECIFICATIONS FOR 1991 Daihatsu Charade AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1991 Daihatsu Charade cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1991 Daihatsu Charade cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1991 Daihatsu Charade cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1991 Daihatsu Charade cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1991 Daihatsu Charade SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1991 Daihatsu Charade vehicle. |
Access the Complete guide! |